Infiniti M35, M45 (Y50-Sereis) Service & Repair Manual 2006-2010
Complete workshop repair service manual with electrical wiring diagrams for Infiniti M35, M45 (Y50) 2006-2010. It's the same service manual used by dealers that guaranteed to be fully functional and intact without any missing page.
This Infiniti M35, M45 (Y50) 2006-2010 service & repair manual (including maintenance, overhaul, disassembling & assembling, adjustment, tune-up, operation, inspecting, diagnostic & troubleshooting…) is divided into different sections. Each section covers a specific component or system with detailed illustrations. A table of contents is placed at the beginning of each section. Pages are easily found by category, and each page is expandable for great detail. The printer-ready PDF documents work like a charm on all kinds of devices.
TABLE OF CONTENTS
QUICK REFERENCE INDEX
GENERAL INFORMATION
MAINTENANCE
ENGINE MECHANICAL
ENGINE LUBRICATION & COOLING SYSTEMS
ENGINE CONTROL SYSTEM
ACCELERATOR CONTROL, FUEL & EXHAUST SYSTEMS
CLUTCH
MANUAL TRANSAXLE
AUTOMATIC TRANSAXLE
FRONT AXLE & FRONT SUSPENSION
REAR AXLE & REAR SUSPENSION
BRAKE SYSTEM
STEERING SYSTEM
RESTRAINT SYSTEM
BODY & TRIM
HEATER & AIR CONDITIONER
ELECTRICAL SYSTEM
ALPHABETICAL INDEX
EXCERPT:
MICROPHONE
Removal and Installation
REMOVAL
1. Remove headlining. Refer to EI-62, "Component Parts Location".
2. Remove connector.
3. Raise tab (A) and remove microphone (1).
INSTALLATION
Install in the reverse order of removal.
BCS....3
Table of Contents....3
SERVICE INFORMATION....4
DTC INDEX....4
U1000-U1010....4
B2192-B2194....4
PRECAUTIONS....5
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5
BCM (BODY CONTROL MODULE)....6
System Description....6
BCM FUNCTION....6
CAN COMMUNICATION CONTROL....6
BCM STATUS CONTROL....6
SYSTEMS CONTROLLED BY BCM DIRECTLY....6
SYSTEMS CONTROLLED BY BCM AND IPDM E/R....7
SYSTEMS CONTROLLED BY BCM AND COMBINATION METER....7
SYSTEMS CONTROLLED BY BCM AND INTELLIGENT KEY UNIT....7
SYSTEMS CONTROLLED BY BCM, COMBINATION METER AND IPDM E/R ....7
SYSTEMS CONTROLLED BY BCM, LOW TIRE PRESSURE WARNING CONTROL UNIT AND COMBINATION METER....7
MAJOR COMPONENTS AND CONTROL SYSTEM....7
Combination Switch Reading Function....9
OUTLINE....9
OPERATION DESCRIPTION....9
OPERATION TABLE OF BCM AND COMBINATION SWITCHES....9
SAMPLE OPERATION....10
OPERATION MODE....10
WIPER DIAL POSITION SETTING....11
CAN Communication Unit....12
Schematic....12
CONSULT-III Function (BCM)....13
ITEMS OF EACH PART....14
WORK SUPPORT....14
SELF-DIAGNOSTIC RESULT....14
U1000 CAN COMM CIRCUIT....15
U1010 CONTROL UNIT (CAN)....15
Check BCM Power Supply and Ground Circuit....15
Removal and Installation of BCM....16
REMOVAL....16
INSTALLATION....16
FFD....17
Table of Contents....17
SERVICE INFORMATION....18
PRECAUTIONS....18
Precaution Necessary for Steering Wheel Rotation After Battery Disconnect....18
OPERATION PROCEDURE....18
Service Notice or Precaution....18
PREPARATION....19
Special Service Tool....19
Commercial Service Tool....21
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....23
NVH Troubleshooting Chart....23
DESCRIPTION....24
Cross-Sectional View....24
DIFFERENTIAL GEAR OIL....25
Changing Differential Gear Oil....25
DRAINING....25
FILLING....25
Checking Differential Gear Oil....25
OIL LEAKAGE AND OIL LEVEL....25
FRONT OIL SEAL....26
Removal and Installation....26
REMOVAL....26
INSTALLATION....26
SIDE OIL SEAL....28
Removal and Installation....28
REMOVAL....28
Right Side:....28
Left Side:....28
INSTALLATION....28
Right Side:....28
Left Side:....28
FRONT FINAL DRIVE ASSEMBLY....30
Removal and Installation (VQ35HR)....30
COMPONENTS....30
REMOVAL....30
INSTALLATION....30
Removal and Installation (VK45DE)....31
COMPONENTS....31
REMOVAL....32
INSTALLATION....32
Disassembly and Assembly ....33
COMPONENTS (VQ35HR)....33
COMPONENTS (VK45DE)....35
ASSEMBLY INSPECTION AND ADJUSTMENT....36
Total Preload Torque....36
Drive Gear Runout....36
Tooth Contact....37
Backlash....39
Companion Flange Runout....39
DISASSEMBLY....40
Side Shaft Assembly....40
Differential Assembly....40
Drive Pinion Assembly....43
INSPECTION AFTER DISASSEMBLY....44
ADJUSTMENT AND SELECTION OF ADJUSTING WASHERS (SHIMS)....44
Differential Side Gear Clearance....45
Side Bearing Preload....45
Pinion Gear Height....47
Pinion Bearing Preload....47
ASSEMBLY....48
Drive Pinion Assembly....48
Differential Assembly....50
Side Shaft Assembly....54
SERVICE DATA AND SPECIFICATIONS (SDS)....55
General Specification....55
Inspection and Adjustment....55
DRIVE GEAR RUNOUT....55
DIFFERENTIAL SIDE GEAR CLEARANCE....55
PRELOAD TORQUE....55
BACKLASH....55
COMPANION FLANGE RUNOUT....55
SELECTIVE PARTS....55
Side Gear Thrust Washer....55
Pinion Height Adjusting Washer....56
Drive Pinion Bearing Adjusting Washer....56
Drive Pinion Adjusting Washer....56
Side Bearing Adjusting Shim....56
Side Bearing Adjusting Washer....56
TF....58
Table of Contents....58
SERVICE INFORMATION....60
DTC INDEX....60
C1201-C1210, U1000, U1010....60
PRECAUTIONS....61
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....61
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....61
Precaution Necessary for Steering Wheel Rotation after Battery Disconnect....61
OPERATION PROCEDURE....61
Precaution....62
Service Notice or Precaution....62
PREPARATION....64
Special Service Tool....64
Commercial Service Tool....65
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....67
NVH Troubleshooting Chart....67
TRANSFER FLUID....68
Replacement....68
DRAINING....68
FILLING....68
Inspection....68
FLUID LEAKAGE AND FLUID LEVEL....68
AWD SYSTEM....69
Power Transfer Diagram....69
System Description....69
DESCRIPTION....69
ELECTRIC CONTROLLED COUPLING....69
Operation Principle....69
AWD CONTROL UNIT....70
AWD WARNING LAMP....70
AWD Warning Lamp Indication....70
Schematic....71
COMPONENTS FUNCTION DESCRIPTION....71
CAN Communication....71
SYSTEM DESCRIPTION ....71
TROUBLE DIAGNOSIS....73
Fail-Safe Function....73
How to Perform Trouble Diagnosis....73
BASIC CONCEPT....73
Location of Electrical Parts....74
Circuit Diagram....75
Wiring Diagram - AWD -....76
Trouble Diagnosis Chart by Symptom....79
AWD Control Unit Input/Output Signal Reference Value....79
AWD CONTROL UNIT INSPECTION TABLE....79
Specifications with CONSULT-III....79
CONSULT-III Function (ALL MODE AWD/4WD)....80
FUNCTION....80
SELF-DIAG RESULT MODE....81
Display Item List....81
How to Erase Self-Diagnostic Results....81
DATA MONITOR MODE....81
Display Item List....81
ACTIVE TEST MODE....82
Description....82
Test Item....82
TROUBLE DIAGNOSIS FOR SYSTEM....84
DTC C1201 CONTROLLER FAILER....84
DIAGNOSTIC PROCEDURE....84
DTC C1203 ABS SYSTEM....84
DIAGNOSTIC PROCEDURE....84
DTC C1204 AWD SOLENOID....85
CONSULT-III REFERENCE VALUE IN DATA MONITOR MODE....85
DIAGNOSTIC PROCEDURE....85
COMPONENT INSPECTION....86
DTC C1205 AWD ACTUATOR RELAY....86
CONSULT-III REFERENCE VALUE IN DATA MONITOR MODE....86
DIAGNOSTIC PROCEDURE....86
DTC C1210 ENGINE CONTROL SIGNAL....87
DIAGNOSTIC PROCEDURE....87
DTC U1000 CAN COMMUNICATION LINE....88
DIAGNOSTIC PROCEDURE....88
DTC U1010 CONTROL UNIT (CAN)....88
DIAGNOSTIC PROCEDURE....88
Power Supply Circuit for AWD Control Unit....88
CONSULT-III REFERENCE VALUE IN DATA MONITOR MODE....88
DIAGNOSTIC PROCEDURE....88
TROUBLE DIAGNOSIS FOR SYMPTOMS....90
AWD Warning Lamp Does Not Turn ON When the Ignition Switch Is Turned to ON....90
DIAGNOSTIC PROCEDURE....90
AWD Warning Lamp Does Not Turn OFF Several Seconds after Engine Started....90
DIAGNOSTIC PROCEDURE....90
Heavy Tight-Corner Braking Symptom Occurs When the Vehicle Is Driven and the Steering Wheel Is Turned Fully to Either Side after the Engine Is Started....92
DIAGNOSTIC PROCEDURE....92
Vehicle Does Not Enter AWD Mode Even Though AWD Warning Lamp Turned to OFF....93
DIAGNOSTIC PROCEDURE....93
While Driving, AWD Warning Lamp Flashes Rapidly (When Flashing in Approx. 1 Minute and Then Turning OFF)....93
While Driving, AWD Warning Lamp Flashes Slowly (When Continuing to Flash until Turning Ignition Switch OFF)....93
DIAGNOSTIC PROCEDURE....94
AWD CONTROL UNIT....95
Removal and Installation....95
REMOVAL....95
INSTALLATION....95
FRONT OIL SEAL....96
Removal and Installation....96
REMOVAL....96
INSTALLATION....96
REAR OIL SEAL....97
Removal and Installation....97
REMOVAL....97
INSTALLATION....98
AIR BREATHER HOSE....99
Removal and Installation....99
TRANSFER ASSEMBLY....101
Removal and Installation....101
REMOVAL....101
INSTALLATION....101
Disassembly and Assembly....101
COMPONENTS....101
DISASSEMBLY....103
Front Case and Rear Case....103
Mainshaft Assembly....108
Front Drive Shaft and Drive Chain....108
INSPECTION ....109
Cases....109
Bearing....109
Shaft....109
Gears and Chain....109
ASSEMBLY....110
Front Drive Shaft and Drive Chain....110
Mainshaft Assembly....111
Front Case and Rear Case....111
SERVICE DATA AND SPECIFICATIONS (SDS)....117
General Specification....117
acc....118
Table of Contents....118
SERVICE INFORMATION....119
PRECAUTIONS....119
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....119
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....119
ACCELERATOR CONTROL SYSTEM....120
Component....120
Removal and Installation....120
REMOVAL....120
INSTALLATION....121
INSPECTION AFTER INSTALLATION....121
acs....122
Table of Contents....122
ASCD....126
SERVICE INFORMATION....126
AUTOMATIC SPEED CONTROL DEVICE (ASCD)....126
Description....126
ICC....127
SERVICE INFORMATION....127
DTC INDEX....127
C1A00-C1A14....127
C1A15-C1A34....127
U0121-U1010....127
PRECAUTIONS....128
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....128
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....128
Precaution for ICC System Service....128
PREPARATION....129
Special Service Tool....129
DESCRIPTION....130
Outline....130
VEHICLE-TO-VEHICLE DISTANCE CONTROL MODE....130
CONVENTIONAL (FIXED SPEED) CRUISE CONTROL MODE....130
BRAKE ASSIST (WITH PREVIEW FUNCTION)....130
Functional Diagram....130
Components Description....132
CAN Communication....133
CAN COMMUNICATION UNIT....133
Switch Operation....133
IN VEHICLE-TO-VEHICLE DISTANCE CONTROL MODE....133
IN CONVENTIONAL (FIXED SPEED) CRUISE CONTROL MODE....134
ICC System Display....134
IN VEHICLE-TO-VEHICLE DISTANCE CONTROL MODE....134
IN CONVENTIONAL (FIXED SPEED) CRUISE CONTROL MODE....134
ACTION TEST....135
ICC System Running Test....135
VEHICLE-TO-VEHICLE DISTANCE CONTROL MODE ....135
Set Checking....135
Check For Increase Of Cruising Speed....135
Check For Decrease Of Cruising Speed....135
Check For Cancellation Of Vehicle-To-Vehicle Distance Control Mode (Normal Driving Condition) In The Following Cases:....135
Check For Restoring Speed That Is Set By Vehicle-To-Vehicle Distance Control Mode Before Cancellation....135
Check For MAIN Switch....135
Check For RESUME/ACCELERATE, SET/COAST, CANCEL Switches....136
Check For Distance Switch....136
CONVENTIONAL (FIXED SPEED) CRUISE CONTROL MODE....136
Set Checking....136
Check For Increase Of Cruising Speed....136
Check For Decrease Of Cruising Speed....137
Check For Cancellation Of Conventional (Fixed Speed) Cruise Control Mode (Normal Driving Condition) In The Following Cases:....137
Check For Restoring Speed That Is Set By Conventional (Fixed Speed) Cruise Control Mode Before ICC Cancellation....137
Check For MAIN Switch....137
Check For RESUME/ACCELERATE, SET/COAST, CANCEL Switches....137
LASER BEAM AIMING ADJUSTMENT....138
Outline....138
Preparation....138
Outline of Adjustment Procedure....138
Setting the ICC Target Board....138
ADJUSTING HEIGHT OF THE TARGET....138
ADJUSTING THE RIGHT-LEFT POSITION OF THE TARGET....139
SETTING THE TARGET....140
Aiming Adjustment....141
CHECK AFTER THE ADJUSTMENT....142
ELECTRICAL UNITS LOCATION....143
Component Parts and Harness Connector Location....143
WIRING DIAGRAM....145
Schematic....145
Wiring Diagram - ICC -....146
TERMINALS AND REFERENCE VALUE....151
Terminal and Reference Value for ICC Sensor Integrated Unit....151
TROUBLE DIAGNOSIS - GENERAL DESCRIPTION....152
Fail-Safe Function....152
Work Flow....152
CONSULT-III Function (ICC)....152
DESCRIPTION....152
WORK SUPPORT....153
Work Item....153
Cause of Auto-Cancel Display Item List....153
Laser Beam Adjust....154
SELF-DIAGNOSTIC RESULTS....154
DATA MONITOR....154
Monitored Item....154
ACTIVE TEST....155
ICC BUZZER....155
METER LAMP....155
STOP LAMP....156
Self-Diagnostic Function....156
WITH CONSULT-III....156
WITHOUT CONSULT-III....156
Self-Diagnostic Erasing Method....157
SELF-DIAGNOSIS BY DOT MATRIX LCD WILL NOT RUN....158
Possible Irregular Condition....158
TROUBLE DIAGNOSIS FOR SELF-DIAGNOSTIC ITEMS....161
Diagnostic Trouble Code (DTC) Chart....161
C1A00 CONTROL UNIT....163
C1A01 POWER SUPPLY CIR, C1A02 POWER SUPPLY CIR 2....163
C1A03 VHCL SPEED SE CIRC....164
C1A04 ABS/TCS/VDC CIRC....164
C1A05 BRAKE SW/STOP L SW....165
C1A06 OPERATION SW CIRC....168
C1A12 LASER BEAM OFFCNTR....170
C1A13 STOP LAMP RLY FIX....170
C1A14 ECM CIRCUIT....176
C1A15 GEAR POSITION....176
C1A16 RADAR STAIN....177
C1A18 LASER AIMING INCMP....178
C1A21 UNIT HIGH TEMP....178
C1A24 NP RANGE....178
C1A25 SHIFT RANGE IND....179
C1A26 ECD MODE MALF....179
C1A27 ECD PWR SUPLY CIR....180
C1A33 CAN TRANSMISSION ERROR....180
C1A34 COMMAND ERROR....180
U0121 VDC CAN CIR2....180
U0401 ECM CAN CIR1....181
U0402 TCM CAN CIR1....181
U0415 VDC CAN CIR1....182
U1000 CAN COMM CIRCUIT....182
U1010 CONTROL UNIT (CAN)....182
TROUBLE DIAGNOSIS FOR SYMPTOMS....183
Symptom Chart....183
Symptom 1 MAIN Switch Does Not Turn ON*1, MAIN Switch Does Not Turn OFF*2....183
Symptom 2 ICC System Cannot Be Set (MAIN Switch Turns ON/OFF)....184
Symptom 3 ICC System Cannot Be Operated by CANCEL Switch, RESUME/ACCELERATE Switch or DISTANCE Switch....185
Symptom 4 ICC System Is Not Cancelled When the A/T Selector Lever Is "N" Position....185
Symptom 5 Chime Does Not Sound....186
Symptom 6 Driving Force Is Hunting....187
Symptom 7 ICC System Frequently Cannot Detect the Vehicle Ahead/ Detection Zone Is Short....187
Symptom 8 the System Does Not Detect the Vehicle Ahead at All....188
ELECTRICAL COMPONENT INSPECTION....189
ICC Steering Switch....189
ICC Brake Hold Relay....189
ICC Brake Switch and Stop Lamp Switch....189
REMOVAL AND INSTALLATION....191
ICC Sensor Integrated Unit....191
REMOVAL....191
INSTALLATION....191
ICC Steering Switch....191
LDW & LDP....192
BASIC INSPECTION....192
DIAGNOSIS AND REPAIR WORK FLOW....192
Work Flow....192
OVERALL SEQUENCE....192
DETAILED FLOW....192
Diagnostic Work Sheet....193
DESCRIPTION....193
WORK SHEET SAMPLE....194
PRE-INSPECTION FOR DIAGNOSIS....195
Inspection Procedure....195
ACTION TEST....196
Description....196
Inspection Procedure....196
INSPECTION AND ADJUSTMENT....198
ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (LANE CAMERA UNIT)....198
ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (LANE CAMERA UNIT) : Description....198
ADDITIONAL SERVICE WHEN REPLACING CONTROL UNIT (LANE CAMERA UNIT) : Special Repair Requirement....198
CAMERA AIMING ADJUSTMENT....198
CAMERA AIMING ADJUSTMENT : Description....198
OUTLINE....198
CAMERA AIMING ADJUSTMENT : Special Repair Requirement (Preparation)....198
CAMERA AIMING ADJUSTMENT : Special Repair Requirement (Target Setting)....199
CAMERA AIMING ADJUSTMENT : Special Repair Requirement (Camera Aiming Adjustment)....200
CAMERA AIMING ADJUSTMENT : Special Repair Requirement (Target Mark Sample)....202
FUNCTION DIAGNOSIS....203
LANE DEPARTURE WARNING (LDW) SYSTEM....203
System Diagram....203
System Description....203
OUTLINE....203
BASIC OPERATIONS....203
Switches And Indicator/Warning Lamps....203
Bulb Check Action and Fail-safe Indication ....204
LDW INITIAL STATE CHANGE....204
LDW SYSTEM CONTROL DESCRIPTION....205
SIGNAL INPUT/OUTPUT BY CAN COMMUNICATION....205
Component Parts Location....206
Component Description....206
LANE DEPARTURE PREVENTION (LDP) SYSTEM....208
System Diagram....208
System Description....208
OUTLINE....208
BASIC OPERATIONS....209
Switches And Indicator/Warning Lamps....209
Bulb Check Action and Fail-safe Indication ....209
LDP SYSTEM CONTROL DESCRIPTION....210
SIGNAL INPUT/OUTPUT BY CAN COMMUNICATION....211
Component Parts Location....213
Component Description....214
DIAGNOSIS SYSTEM (LANE CAMERA UNIT)....216
CONSULT-III Function (LANE CAMERA)....216
DESCRIPTION....216
WORK SUPPORT....216
Cause of Auto-Cancel Display Item List....216
SELF DIAGNOSTIC RESULT....217
DATA MONITOR....217
ACTIVE TEST....217
DIAGNOSIS SYSTEM [ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)]....219
CONSULT-III Function (ABS)....219
FUNCTION....219
WORK SUPPORT....219
SELF-DIAG RESULTS MODE....219
Operation Procedure....219
How to Erase Self-diagnosis Results....219
Display Item List....219
DATA MONITOR MODE....222
Display Item List....222
ACTIVE TEST MODE....225
Test Item....225
ECU PART NUMBER....227
COMPONENT DIAGNOSIS....228
C1B00 CAMERA UNIT MALF....228
DTC Logic....228
DTC DETECTION LOGIC....228
Diagnosis Procedure....228
C1B01 CAM AIMING INCMP....229
DTC Logic....229
DTC DETECTION LOGIC....229
Diagnosis Procedure....229
C1B02 VHCL SPD DATA MALF....230
DTC Logic....230
DTC DETECTION LOGIC....230
DTC CONFIRMATION PROCEDURE....230
Diagnosis Procedure....230
C1B03 ABNRML TEMP DETECT....231
DTC Logic....231
DTC DETECTION LOGIC....231
Diagnosis Procedure....231
C1B07 ABS DIAGNOSIS....232
DTC Logic....232
DTC DETECTION LOGIC....232
Diagnosis Procedure....232
U1000 CAN COMM CIRCUIT....233
Description....233
DTC Logic....233
DTC DETECTION LOGIC....233
Diagnosis Procedure....233
U1010 CONTROL UNIT (CAN)....234
DTC Logic....234
DTC DETECTION LOGIC....234
Diagnosis Procedure....234
U0122 VDC CAN CIR1 (LDP)....235
DTC Logic....235
DTC DETECTION LOGIC....235
DTC CONFIRMATION PROCEDURE....235
Diagnosis Procedure....235
U0416 VDC CAN CIR2 (LDP)....237
DTC Logic....237
DTC DETECTION LOGIC....237
DTC CONFIRMATION PROCEDURE....237
Diagnosis Procedure....237
C1B00 LDP) CAMERA MALF....239
DTC Logic....239
DTC DETECTION LOGIC....239
Diagnosis Procedure....239
C1B04 LDP) ICC STG SW MALF....240
DTC Logic....240
DTC DETECTION LOGIC....240
Diagnosis Procedure....240
C1B05 LDP) APP SEN MALF....241
DTC Logic....241
DTC DETECTION LOGIC....241
Diagnosis Procedure....241
C1B06 LDP) TCM MALF....242
DTC Logic....242
DTC DETECTION LOGIC....242
Diagnosis Procedure....242
U0100 LDP) ECM CAN CIR2....243
DTC Logic....243
DTC DETECTION LOGIC....243
DTC CONFIRMATION PROCEDURE....243
Diagnosis Procedure....243
U0101 LDP) TCM CAM CAN CIR2....245
DTC Logic....245
DTC DETECTION LOGIC....245
DTC CONFIRMATION PROCEDURE....245
Diagnosis Procedure....245
U0104 LDP) ICC CAM CAN CIR2....246
DTC Logic....246
DTC DETECTION LOGIC....246
DTC CONFIRMATION PROCEDURE....246
Diagnosis Procedure....246
U0405 LDP) ICC CAM CAN CIR1....247
DTC Logic....247
DTC DETECTION LOGIC....247
DTC CONFIRMATION PROCEDURE....247
Diagnosis Procedure....247
U1500 LDP) CAM CAN CIR1....248
DTC Logic....248
DTC DETECTION LOGIC....248
DTC CONFIRMATION PROCEDURE....248
Diagnosis Procedure....248
U1501 LDP) CAM CAN CIR2....249
DTC Logic....249
DTC DETECTION LOGIC....249
DTC CONFIRMATION PROCEDURE....249
Diagnosis Procedure....249
POWER SUPPLY AND GROUND CIRCUIT....250
LANE CAMERA UNIT....250
LANE CAMERA UNIT : Diagnosis Procedure....250
ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)....250
ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT) : ABS Actuator and Electric Unit (Control Unit) Power Supply and Ground Circuit....250
INSPECTION PROCEDURE....250
LDW SWITCH CIRCUIT....252
Component Function Check....252
Diagnosis Procedure....252
Component Inspection....253
LDW ON INDICATOR CIRCUIT....254
Component Function Check....254
Diagnosis Procedure....254
LANE DEPARTURE WARNING BUZZER CIRCUIT....256
Component Function Check....256
Diagnosis Procedure....256
LANE DEPARTURE WARNING LAMP CIRCUIT....258
Component Function Check....258
Diagnosis Procedure....258
LDP ON INDICATOR LAMP CIRCUIT....259
Component Function Check....259
Diagnosis Procedure....259
ECU DIAGNOSIS....260
LANE CAMERA UNIT....260
Reference Value....260
VALUES ON THE DIAGNOSIS TOOL....260
TERMINAL LAYOUT....261
PHYSICAL VALUES....261
Schematic....263
Wiring Diagram - LDW & LDP -....264
Fail-safe....267
FAIL-SAFE CONTROL BY DTC....267
TEMPORARY DISABLED STATUS AT HIGH TEMPERATURE....267
DTC Inspection Priority Chart....268
DTC Index....268
ABS ACTUATOR AND ELECTRIC UNIT (CONTROL UNIT)....269
Reference Value....269
VALUES ON THE DIAGNOSIS TOOL....269
Schematic....275
Wiring Diagram - VDC -....276
Fail-safe....281
ABS, EBD SYSTEM....281
VDC / TCS ....282
LDW/LDP SYSTEM....282
DTC No. Index....282
SYMPTOM DIAGNOSIS....284
LDW & LDP SYSTEM SYMPTOMS....284
Symptom Table....284
NORMAL OPERATING CONDITION....286
Description....286
LANE DEPARTURE WARNING (LDW)....286
LANE DEPARTURE PREVENTION (LDP)....286
PRECAUTION....288
PRECAUTIONS....288
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....288
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....288
Precaution for LDW/LDP System Service....288
ON-VEHICLE REPAIR....289
LANE CAMERA UNIT....289
Exploded View....289
Removal and Installation....289
REMOVAL....289
INSTALLATION....289
LDW SWITCH....290
Exploded View....290
Removal and Installation....290
REMOVAL....290
INSTALLATION....290
LANE DEPARTURE WARNING BUZZER....291
Exploded View....291
Removal and Installation....291
REMOVAL....291
INSTALLATION....291
LDP ON SWITCH....292
Exploded View....292
at....293
Table of Contents....293
5AT: RE5R05A....300
SERVICE INFORMATION....300
INDEX FOR DTC....300
Alphabetical Index....300
DTC No. Index....300
PRECAUTIONS....302
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....302
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....302
Precaution for On Board Diagnosis (OBD) System of A/T and Engine....302
Precaution....303
Service Notice or Precaution....304
ATF COOLER SERVICE....304
OBD-II SELF-DIAGNOSIS....304
PREPARATION....305
Special Service Tool....305
Commercial Service Tool....306
A/T FLUID....307
VQ35HR....307
VQ35HR : Changing A/T Fluid....307
VQ35HR : Adjusting A/T Fluid....308
VQ35HR : A/T Fluid Cooler Cleaning....309
A/T FLUID COOLER CLEANING PROCEDURE....309
A/T FLUID COOLER DIAGNOSIS PROCEDURE....310
A/T FLUID COOLER INSPECTION PROCEDURE....311
A/T FLUID COOLER FINAL INSPECTION....311
VK45DE....311
VK45DE : Changing A/T Fluid....311
VK45DE : Checking A/T Fluid....312
VK45DE : A/T Fluid Cooler Cleaning....313
A/T FLUID COOLER CLEANING PROCEDURE....314
A/T FLUID COOLER DIAGNOSIS PROCEDURE....314
A/T FLUID COOLER INSPECTION PROCEDURE....315
A/T FLUID COOLER FINAL INSPECTION....316
A/T CONTROL SYSTEM....317
Cross-Sectional View (VQ35HR Models)....317
Cross-Sectional View (VK45DE Models for 2WD)....318
Cross-Sectional View (VK45DE Models for AWD)....319
Shift Mechanism....319
CONSTRUCTION ....319
FUNCTION OF CLUTCH AND BRAKE ....320
CLUTCH AND BAND CHART....321
POWER TRANSMISSION ....321
“N” Position....321
“P” Position....321
“D1” Position....322
“M1” Position....323
“D2” Position....324
“M2” Position....325
“D3” and “M3” Positions....326
“D4” and “M4” Positions....327
“D5” and “M5” Positions....328
“R” Position....329
TCM Function....330
CONTROL SYSTEM OUTLINE ....330
CONTROL SYSTEM DIAGRAM....331
CAN Communication....331
SYSTEM DESCRIPTION ....331
Input/Output Signal of TCM....332
Line Pressure Control....332
LINE PRESSURE CONTROL IS BASED ON THE TCM LINE PRESSURE CHARACTERISTIC PATTERN ....333
Normal Control....333
Back-up Control (Engine Brake)....333
During Shift Change....333
At Low Fluid Temperature....334
Shift Control....334
SHIFT CHANGE ....334
Shift Change System Diagram....334
BLIPPING CONTROL....335
Shift Change System Diagram....335
ASC (ADOPTIVE SHIFT CONTROL)....335
When Driving on an Up/Down Slope....336
When Driving on a Curve....336
Lock-up Control....336
TORQUE CONVERTER CLUTCH CONTROL VALVE CONTROL ....336
Lock-up Control System Diagram....336
Lock-up Released ....336
Lock-up Applied....337
SMOOTH LOCK-UP CONTROL ....337
Half-clutched State....337
Slip Lock-up Control....337
Engine Brake Control....337
Control Valve....337
FUNCTION OF CONTROL VALVE ....337
FUNCTION OF PRESSURE SWITCH ....338
ON BOARD DIAGNOSTIC (OBD) SYSTEM....339
Introduction....339
OBD-II Function for A/T System....339
One or Two Trip Detection Logic of OBD-II....339
ONE TRIP DETECTION LOGIC....339
TWO TRIP DETECTION LOGIC....339
OBD-II Diagnostic Trouble Code (DTC)....339
HOW TO READ DTC AND 1ST TRIP DTC....339
Freeze Frame Data and 1st Trip Freeze Frame Data....339
HOW TO ERASE DTC....340
HOW TO ERASE DTC (WITH CONSULT-III)....340
HOW TO ERASE DTC (WITH GST)....340
HOW TO ERASE DTC (NO TOOLS)....340
Malfunction Indicator Lamp (MIL)....341
DESCRIPTION ....341
TROUBLE DIAGNOSIS....342
DTC Inspection Priority Chart....342
Fail-Safe....342
FAIL-SAFE FUNCTION....342
Output Speed Sensor....342
Accelerator Pedal Position Sensor....342
Throttle Position Sensor....342
Transmission Range Switch....342
Starter Relay....342
Interlock....342
1st Engine Braking....342
Line Pressure Solenoid....343
Torque Converter Clutch Solenoid....343
Low Coast Brake Solenoid....343
Input Clutch Solenoid....343
Direct Clutch Solenoid....343
Front Brake Solenoid....343
High and Low Reverse Clutch Solenoid....343
Input Speed Sensor 1 or 2....343
How to Perform Trouble Diagnosis for Quick and Accurate Repair....343
INTRODUCTION....343
WORK FLOW....344
Work Flow Chart....344
DIAGNOSTIC WORKSHEET....345
Information from Customer....345
Diagnostic Worksheet Chart....345
A/T Electrical Parts Location....348
Circuit Diagram....349
Inspections Before Trouble Diagnosis....349
A/T FLUID CHECK (VK45DE MODELS ONLY)....349
A/T Fluid Leakage and A/T Fluid Level Check ....349
A/T Fluid Condition Check....350
STALL TEST....350
Stall Test Procedure....350
Judgment of Stall Test....351
LINE PRESSURE TEST ....351
Line Pressure Test Port....351
Line Pressure Test Procedure....352
Line Pressure....353
Judgment of Line Pressure Test....353
Road Test....353
DESCRIPTION....353
CHECK BEFORE ENGINE IS STARTED....353
CHECK AT IDLE....354
CRUISE TEST - PART 1....355
CRUISE TEST - PART 2....357
CRUISE TEST - PART 3....357
Vehicle Speed at Which Gear Shifting Occurs....358
2WD MODELS....358
AWD MODELS....358
Vehicle Speed at Which Lock-Up Occurs/Releases....359
2WD MODELS....359
AWD MODELS....359
Symptom Chart....359
TCM Input/Output Signal Reference Value....383
A/T ASSEMBLY HARNESS CONNECTOR TERMINAL LAYOUT ....383
TCM INSPECTION TABLE....383
CONSULT-III Function (TRANSMISSION)....384
FUNCTION....384
CONSULT-III REFERENCE VALUE....384
SELF-DIAGNOSTIC RESULT MODE....385
Display Items List....385
DATA MONITOR MODE....387
Display Items List....387
DTC WORK SUPPORT MODE ....390
Display Items List....390
Diagnosis Procedure without CONSULT-III....391
OBD-II SELF-DIAGNOSTIC PROCEDURE (WITH GST)....391
OBD-II SELF-DIAGNOSTIC PROCEDURE (NO TOOLS)....391
TCM SELF-DIAGNOSTIC PROCEDURE (NO TOOLS)....391
Description....391
Operation Procedure....391
Judgment Self-diagnosis Code....392
Erase Self-diagnosis....393
U1000 CAN COMM CIRCUIT....394
Description....394
On Board Diagnosis Logic....394
Possible Cause....394
DTC Confirmation Procedure....394
WITH CONSULT-III....394
WITH GST....394
Wiring Diagram - AT - CAN....395
Diagnosis Procedure....396
P0615 STARTER RELAY....397
Description....397
CONSULT-III Reference Value in Data Monitor Mode....397
On Board Diagnosis Logic....397
Possible Cause....397
DTC Confirmation Procedure....397
WITH CONSULT-III....397
Wiring Diagram - AT - STSIG....398
Diagnosis Procedure....399
P0700 TRANSMISSION CONTROL....401
Description....401
On Board Diagnosis Logic....401
Possible Cause....401
DTC Confirmation Procedure....401
WITH CONSULT-III....401
WITH GST....401
Diagnosis Procedure....401
P0705 TRANSMISSION RANGE SWITCH A....402
Description....402
CONSULT-III Reference Value in Data Monitor Mode....402
On Board Diagnosis Logic....402
Possible Cause....402
DTC Confirmation Procedure....402
WITH CONSULT-III....402
WITH GST....402
Wiring Diagram - AT - TR/SW....403
Diagnosis Procedure....403
P0717 INPUT SPEED SENSOR A....405
Description....405
CONSULT-III Reference Value in Data Monitor Mode....405
On Board Diagnosis Logic....405
Possible Cause....405
DTC Confirmation Procedure....405
WITH CONSULT-III....405
WITH GST....405
Diagnosis Procedure....405
P0720 OUTPUT SPEED SENSOR....407
Description....407
CONSULT-III Reference Value in Data Monitor Mode....407
On Board Diagnosis Logic....407
Possible Cause....407
DTC Confirmation Procedure....407
WITH CONSULT-III....407
WITH GST....408
Wiring Diagram - AT - VSSA/T....409
Diagnosis Procedure....409
P0725 ENGINE SPEED....412
Description....412
CONSULT-III Reference Value in Data Monitor Mode....412
On Board Diagnosis Logic....412
Possible Cause....412
DTC Confirmation Procedure....412
WITH CONSULT-III....412
WITH GST....412
Diagnosis Procedure....412
P0731 1GR INCORRECT RATIO....414
Description....414
On Board Diagnosis Logic....414
Possible Cause....414
DTC Confirmation Procedure....414
WITH CONSULT-III....414
WITH GST....415
Diagnosis Procedure....415
P0732 2GR INCORRECT RATIO....416
Description....416
On Board Diagnosis Logic....416
Possible Cause....416
DTC Confirmation Procedure....416
WITH CONSULT-III....416
WITH GST....417
Diagnosis Procedure....417
P0733 3GR INCORRECT RATIO....418
Description....418
On Board Diagnosis Logic....418
Possible Cause....418
DTC Confirmation Procedure....418
WITH CONSULT-III....418
WITH GST....419
Diagnosis Procedure....419
P0734 4GR INCORRECT RATIO....420
Description....420
On Board Diagnosis Logic....420
Possible Cause....420
DTC Confirmation Procedure....420
WITH CONSULT-III....420
WITH GST....421
Diagnosis Procedure....421
P0735 5GR INCORRECT RATIO....422
Description....422
On Board Diagnosis Logic....422
Possible Cause....422
DTC Confirmation Procedure....422
WITH CONSULT-III....422
WITH GST....423
Diagnosis Procedure....423
P0740 TORQUE CONVERTER....424
Description....424
CONSULT-III Reference Value in Data Monitor Mode....424
On Board Diagnosis Logic....424
Possible Cause....424
DTC Confirmation Procedure....424
WITH CONSULT-III....424
WITH GST....424
Diagnosis Procedure....424
P0744 TORQUE CONVERTER....426
Description....426
CONSULT-III Reference Value in Data Monitor Mode....426
On Board Diagnosis Logic....426
Possible Cause....426
DTC Confirmation Procedure....426
WITH CONSULT-III....426
WITH GST....426
Diagnosis Procedure....426
P0745 PRESSURE CONTROL SOLENOID A....428
Description....428
CONSULT-III Reference Value in Data Monitor Mode....428
On Board Diagnosis Logic....428
Possible Cause....428
DTC Confirmation Procedure....428
WITH CONSULT-III....428
WITH GST....428
Diagnosis Procedure....428
P1705 TP SENSOR....430
Description....430
CONSULT-III Reference Value in Data Monitor Mode....430
On Board Diagnosis Logic....430
Possible Cause....430
DTC Confirmation Procedure....430
WITH CONSULT-III....430
WITH GST....430
Diagnosis Procedure....430
P1710 TRANSMISSION FLUID TEMPERATURE SENSOR....432
Description....432
CONSULT-III Reference Value in Data Monitor Mode....432
On Board Diagnosis Logic....432
Possible Cause....432
DTC Confirmation Procedure....432
WITH CONSULT-III....432
WITH GST....432
Wiring Diagram - AT - FTS....433
Diagnosis Procedure....433
Component Inspection....435
A/T FLUID TEMPERATURE SENSOR 1....435
A/T FLUID TEMPERATURE SENSOR 2....435
P1721 VEHICLE SPEED SIGNAL....437
Description....437
CONSULT-III Reference Value in Data Monitor Mode....437
On Board Diagnosis Logic....437
Possible Cause....437
DTC Confirmation Procedure....437
WITH CONSULT-III....437
Diagnosis Procedure....437
P1730 INTERLOCK....439
Description....439
On Board Diagnosis Logic....439
CAN Communication Unit....4481
Schematic....4482
Wiring Diagram - DEF -....4483
Terminal and Reference Value for BCM....4487
Terminal and Reference Value for IPDM E/R....4487
CONSULT-III Function (BCM)....4487
DATA MONITOR....4487
Display Item List....4487
ACTIVE TEST....4487
Display Item List....4487
CONSULT-III Function (IPDM E/R)....4488
DATA MONITOR....4488
ACTIVE TEST....4488
Work Flow....4488
Trouble Diagnosis Symptom Chart....4488
Check BCM Power Supply and Ground Circuit....4489
Check Rear Window Defogger Switch Circuit....4489
Check Rear Window Defogger Power Supply Circuit....4490
Check Rear Window Defogger Circuit....4492
Check Door Mirror Defogger Power Supply Circuit....4493
Check Driver Side Door Mirror Defogger Circuit....4495
Check Passenger Side Door Mirror Defogger Circuit....4496
Check Filament....4497
Filament Repair....4498
REPAIR EQUIPMENT....4498
REPAIRING PROCEDURE....4498
REVERSE INTERLOCK DOOR MIRROR SYSTEM....4500
Component Parts and Harness Connector Location....4500
System Description....4500
OPERATION CONDITIONS....4500
MIRROR UNGLE MEMORY FUNCTION....4500
REVERSE INTERLOCK DOOR MIRROR SYSTEM OPERATION....4501
CAN Communication System Description....4501
CAN Communication Unit....4501
Schematic....4502
Wiring Diagram - MIRROR -....4503
Terminal and Reference Value for Automatic Drive Positioner Control Unit....4509
Terminal and Reference Value for Driver Seat Control Unit....4510
CONSULT-III Function (AUTO DRIVE POS.)....4510
DATA MONITOR....4511
Selection from Menu....4511
ACTIVE TEST....4511
Display Item List....4511
Work Flow....4512
Symptom Chart....4512
Check Changeover Switch Circuit....4512
Check Mirror Switch Circuit....4514
Check Mirror Motor Circuit....4516
Check Mirror Sensor Circuit....4519
Check A/T Shift Selector R Position Circuit....4522
DOOR MIRROR....4523
Automatic Drive Positioner Interlocking Door Mirror....4523
Removal and Installation....4523
REMOVAL....4523
INSTALLATION....4523
Disassembly and Assembly....4524
DISASSEMBLY....4524
ASSEMBLY....4525
ip....4526
Table of Contents....4526
SERVICE INFORMATION....4527
PRECAUTIONS....4527
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....4527
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....4527
Precaution Necessary for Steering Wheel Rotation after Battery Disconnect....4527
OPERATION PROCEDURE....4527
Precaution....4528
PREPARATION....4529
Special Service Tools....4529
Commercial Service Tools....4529
SQUEAK AND RATTLE TROUBLE DIAGNOSES....4530
Work Flow....4530
CUSTOMER INTERVIEW....4530
DUPLICATE THE NOISE AND TEST DRIVE....4530
CHECK RELATED SERVICE BULLETINS....4531
LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE....4531
REPAIR THE CAUSE....4531
CONFIRM THE REPAIR....4532
Inspection Procedure....4532
INSTRUMENT PANEL....4532
CENTER CONSOLE....4532
DOORS....4532
TRUNK....4532
SUNROOF/HEADLINING....4533
SEATS....4533
UNDERHOOD....4533
Diagnostic Worksheet....4534
INSTRUMENT PANEL ASSEMBLY....4536
INSTRUMENT PANEL....4536
INSTRUMENT PANEL : Component Parts Location....4536
INSTRUMENT PANEL : Removal and Installation....4537
REMOVAL....4537
INSTALLATION....4540
CLUSTER LID A....4540
CLUSTER LID A : Component Parts Location....4541
CLUSTER LID A : Removal and Installation....4541
REMOVAL....4541
INSTALLATION....4542
CLUSTER LID C....4542
CLUSTER LID C : Component Parts Location....4543
CLUSTER LID C : Removal and Installation....4543
REMOVAL....4543
INSTALLATION....4544
GLOVE BOX....4544
GLOVE BOX : Component Parts Location....4544
GLOVE BOX : Removal and Installation....4544
REMOVAL....4544
INSTALLATION....4545
CENTER CONSOLE ASSEMBLY ....4546
CENTER CONSOLE ....4546
CENTER CONSOLE : Component Parts Location....4546
CENTER CONSOLE : Disassembly and Assembly....4546
DISASSEMBLY....4546
ASSEMBLY....4546
lan....4547
Table of Contents....4547
CAN FUNDAMENTAL....4556
PRECAUTION....4556
PRECAUTIONS....4556
Precautions for Trouble Diagnosis....4556
Precautions for Harness Repair....4556
FUNCTION DIAGNOSIS....4557
CAN COMMUNICATION SYSTEM....4557
System Description....4557
System Diagram....4557
CAN Communication Control Circuit....4558
DIAG ON CAN....4559
Description....4559
System Diagram....4559
TROUBLE DIAGNOSIS....4560
Condition of Error Detection....4560
CAN COMMUNICATION SYSTEM ERROR....4560
WHEN “U1000” OR “U1001” IS INDICATED EVEN THOUGH CAN COMMUNICATION SYSTEM IS NORMAL....4560
Symptom When Error Occurs in CAN Communication System....4560
ERROR EXAMPLE....4560
Example: TCM branch line open circuit....4560
Example: Data link connector branch line open circuit....4561
Example: Main Line Between Data Link Connector and ABS Actuator and Electric Unit (Control Unit) Open Circuit....4562
Example: CAN-H, CAN-L Harness Short Circuit....4562
CAN Diagnosis with CONSULT-III....4563
Self-Diagnosis....4563
CAN Diagnostic Support Monitor....4563
MONITOR ITEM (CONSULT-III)....4563
Without PAST....4564
With PAST....4564
MONITOR ITEM (ON-BOARD DIAGNOSIS)....4564
How to Use CAN Communication Signal Chart....4565
BASIC INSPECTION....4566
DIAGNOSIS AND REPAIR WORKFLOW....4566
Trouble Diagnosis Flow Chart....4566
Trouble Diagnosis Procedure....4566
INTERVIEW WITH CUSTOMER....4566
INSPECTION OF VEHICLE CONDITION....4567
CHECK OF CAN SYSTEM TYPE (HOW TO USE CAN SYSTEM TYPE SPECIFICATION CHART)....4567
CAN System Type Specification Chart (Style A)....4567
CAN System Type Specification Chart (Style B)....4568
CREATE INTERVIEW SHEET....4569
Interview Sheet (Example)....4570
DETECT THE ROOT CAUSE....4570
CAN....4571
HOW TO USE THIS MANUAL....4571
HOW TO USE THIS SECTION....4571
Caution....4571
Abbreviation List....4571
PRECAUTION....4572
PRECAUTIONS....4572
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....4572
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....4572
Precautions for Trouble Diagnosis....4572
Precautions for Harness Repair....4572
BASIC INSPECTION....4574
DIAGNOSIS AND REPAIR WORKFLOW....4574
Interview Sheet....4574
FUNCTION DIAGNOSIS....4575
CAN COMMUNICATION SYSTEM....4575
CAN System Specification Chart....4575
VEHICLE EQUIPMENT IDENTIFICATION INFORMATION....4575
CAN Communication Signal Chart....4575
COMPONENT DIAGNOSIS....4580
CAN COMMUNICATION SYSTEM....4580
Component Parts Location....4580
Schematic....4581
Wiring Diagram - CAN -....4582
MALFUNCTION AREA CHART....4588
Main Line....4588
Branch Line....4588
Short Circuit....4588
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4589
Diagnosis Procedure....4589
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4590
Diagnosis Procedure....4590
MAIN LINE BETWEEN DLC AND RAS CIRCUIT....4592
Diagnosis Procedure....4592
MAIN LINE BETWEEN RAS AND PSB CIRCUIT....4593
Diagnosis Procedure....4593
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4594
Diagnosis Procedure....4594
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4595
Diagnosis Procedure....4595
MAIN LINE BETWEEN ABS AND ICC CIRCUIT....4596
Diagnosis Procedure....4596
ECM BRANCH LINE CIRCUIT....4597
Diagnosis Procedure....4597
4WD BRANCH LINE CIRCUIT....4598
Diagnosis Procedure....4598
AFS BRANCH LINE CIRCUIT....4599
Diagnosis Procedure....4599
AV BRANCH LINE CIRCUIT....4600
Diagnosis Procedure....4600
BCM BRANCH LINE CIRCUIT....4601
Diagnosis Procedure....4601
TCM BRANCH LINE CIRCUIT....4602
Diagnosis Procedure....4602
DLC BRANCH LINE CIRCUIT....4603
Diagnosis Procedure....4603
I-KEY BRANCH LINE CIRCUIT....4604
Diagnosis Procedure....4604
LANE BRANCH LINE CIRCUIT....4605
Diagnosis Procedure....4605
M&A BRANCH LINE CIRCUIT....4606
Diagnosis Procedure....4606
STRG BRANCH LINE CIRCUIT....4607
Diagnosis Procedure....4607
TPMS BRANCH LINE CIRCUIT....4608
Diagnosis Procedure....4608
RAS BRANCH LINE CIRCUIT....4609
Diagnosis Procedure....4609
PSB BRANCH LINE CIRCUIT....4610
Diagnosis Procedure....4610
ADP BRANCH LINE CIRCUIT....4611
Diagnosis Procedure....4611
ABS BRANCH LINE CIRCUIT....4612
Diagnosis Procedure....4612
ICC BRANCH LINE CIRCUIT....4613
Diagnosis Procedure....4613
IPDM-E BRANCH LINE CIRCUIT....4614
Diagnosis Procedure....4614
CAN COMMUNICATION CIRCUIT....4615
Diagnosis Procedure....4615
CAN SYSTEM (TYPE 1)....4617
COMPONENT DIAGNOSIS....4617
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4617
Diagnosis Procedure....4617
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4618
Diagnosis Procedure....4618
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4620
Diagnosis Procedure....4620
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4621
Diagnosis Procedure....4621
ECM BRANCH LINE CIRCUIT....4622
Diagnosis Procedure....4622
AFS BRANCH LINE CIRCUIT....4623
Diagnosis Procedure....4623
AV BRANCH LINE CIRCUIT....4624
Diagnosis Procedure....4624
BCM BRANCH LINE CIRCUIT....4625
Diagnosis Procedure....4625
TCM BRANCH LINE CIRCUIT....4626
Diagnosis Procedure....4626
DLC BRANCH LINE CIRCUIT....4627
Diagnosis Procedure....4627
I-KEY BRANCH LINE CIRCUIT....4628
Diagnosis Procedure....4628
M&A BRANCH LINE CIRCUIT....4629
Diagnosis Procedure....4629
STRG BRANCH LINE CIRCUIT....4630
Diagnosis Procedure....4630
TPMS BRANCH LINE CIRCUIT....4631
Diagnosis Procedure....4631
PSB BRANCH LINE CIRCUIT....4632
Diagnosis Procedure....4632
ADP BRANCH LINE CIRCUIT....4633
Diagnosis Procedure....4633
ABS BRANCH LINE CIRCUIT....4634
Diagnosis Procedure....4634
IPDM-E BRANCH LINE CIRCUIT....4635
Diagnosis Procedure....4635
CAN COMMUNICATION CIRCUIT....4636
Diagnosis Procedure....4636
CAN SYSTEM (TYPE 2)....4638
COMPONENT DIAGNOSIS....4638
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4638
Diagnosis Procedure....4638
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4639
Diagnosis Procedure....4639
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4641
Diagnosis Procedure....4641
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4642
Diagnosis Procedure....4642
MAIN LINE BETWEEN ABS AND ICC CIRCUIT....4643
Diagnosis Procedure....4643
ECM BRANCH LINE CIRCUIT....4644
Diagnosis Procedure....4644
AFS BRANCH LINE CIRCUIT....4645
Diagnosis Procedure....4645
AV BRANCH LINE CIRCUIT....4646
Diagnosis Procedure....4646
BCM BRANCH LINE CIRCUIT....4647
Diagnosis Procedure....4647
TCM BRANCH LINE CIRCUIT....4648
Diagnosis Procedure....4648
DLC BRANCH LINE CIRCUIT....4649
Diagnosis Procedure....4649
I-KEY BRANCH LINE CIRCUIT....4650
Diagnosis Procedure....4650
LANE BRANCH LINE CIRCUIT....4651
Diagnosis Procedure....4651
M&A BRANCH LINE CIRCUIT....4652
Diagnosis Procedure....4652
STRG BRANCH LINE CIRCUIT....4653
Diagnosis Procedure....4653
TPMS BRANCH LINE CIRCUIT....4654
Diagnosis Procedure....4654
PSB BRANCH LINE CIRCUIT....4655
Diagnosis Procedure....4655
ADP BRANCH LINE CIRCUIT....4656
Diagnosis Procedure....4656
ABS BRANCH LINE CIRCUIT....4657
Diagnosis Procedure....4657
ICC BRANCH LINE CIRCUIT....4658
Diagnosis Procedure....4658
IPDM-E BRANCH LINE CIRCUIT....4659
Diagnosis Procedure....4659
CAN COMMUNICATION CIRCUIT....4660
Diagnosis Procedure....4660
CAN SYSTEM (TYPE 3)....4662
COMPONENT DIAGNOSIS....4662
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4662
Diagnosis Procedure....4662
MAIN LINE BETWEEN DLC AND RAS CIRCUIT....4663
Diagnosis Procedure....4663
MAIN LINE BETWEEN RAS AND PSB CIRCUIT....4664
Diagnosis Procedure....4664
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4665
Diagnosis Procedure....4665
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4666
Diagnosis Procedure....4666
ECM BRANCH LINE CIRCUIT....4667
Diagnosis Procedure....4667
AFS BRANCH LINE CIRCUIT....4668
Diagnosis Procedure....4668
AV BRANCH LINE CIRCUIT....4669
Diagnosis Procedure....4669
BCM BRANCH LINE CIRCUIT....4670
Diagnosis Procedure....4670
TCM BRANCH LINE CIRCUIT....4671
Diagnosis Procedure....4671
DLC BRANCH LINE CIRCUIT....4672
Diagnosis Procedure....4672
I-KEY BRANCH LINE CIRCUIT....4673
Diagnosis Procedure....4673
M&A BRANCH LINE CIRCUIT....4674
Diagnosis Procedure....4674
STRG BRANCH LINE CIRCUIT....4675
Diagnosis Procedure....4675
TPMS BRANCH LINE CIRCUIT....4676
Diagnosis Procedure....4676
RAS BRANCH LINE CIRCUIT....4677
Diagnosis Procedure....4677
PSB BRANCH LINE CIRCUIT....4678
Diagnosis Procedure....4678
ADP BRANCH LINE CIRCUIT....4679
Diagnosis Procedure....4679
ABS BRANCH LINE CIRCUIT....4680
Diagnosis Procedure....4680
IPDM-E BRANCH LINE CIRCUIT....4681
Diagnosis Procedure....4681
CAN COMMUNICATION CIRCUIT....4682
Diagnosis Procedure....4682
CAN SYSTEM (TYPE 4)....4684
COMPONENT DIAGNOSIS....4684
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4684
Diagnosis Procedure....4684
MAIN LINE BETWEEN DLC AND RAS CIRCUIT....4685
Diagnosis Procedure....4685
MAIN LINE BETWEEN RAS AND PSB CIRCUIT....4686
Diagnosis Procedure....4686
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4687
Diagnosis Procedure....4687
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4688
Diagnosis Procedure....4688
MAIN LINE BETWEEN ABS AND ICC CIRCUIT....4689
Diagnosis Procedure....4689
ECM BRANCH LINE CIRCUIT....4690
Diagnosis Procedure....4690
AFS BRANCH LINE CIRCUIT....4691
Diagnosis Procedure....4691
AV BRANCH LINE CIRCUIT....4692
Diagnosis Procedure....4692
BCM BRANCH LINE CIRCUIT....4693
Diagnosis Procedure....4693
TCM BRANCH LINE CIRCUIT....4694
Diagnosis Procedure....4694
DLC BRANCH LINE CIRCUIT....4695
Diagnosis Procedure....4695
I-KEY BRANCH LINE CIRCUIT....4696
Diagnosis Procedure....4696
LANE BRANCH LINE CIRCUIT....4697
Diagnosis Procedure....4697
M&A BRANCH LINE CIRCUIT....4698
Diagnosis Procedure....4698
STRG BRANCH LINE CIRCUIT....4699
Diagnosis Procedure....4699
TPMS BRANCH LINE CIRCUIT....4700
Diagnosis Procedure....4700
RAS BRANCH LINE CIRCUIT....4701
Diagnosis Procedure....4701
PSB BRANCH LINE CIRCUIT....4702
Diagnosis Procedure....4702
ADP BRANCH LINE CIRCUIT....4703
Diagnosis Procedure....4703
ABS BRANCH LINE CIRCUIT....4704
Diagnosis Procedure....4704
ICC BRANCH LINE CIRCUIT....4705
Diagnosis Procedure....4705
IPDM-E BRANCH LINE CIRCUIT....4706
Diagnosis Procedure....4706
CAN COMMUNICATION CIRCUIT....4707
Diagnosis Procedure....4707
CAN SYSTEM (TYPE 5)....4709
COMPONENT DIAGNOSIS....4709
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4709
Diagnosis Procedure....4709
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4710
Diagnosis Procedure....4710
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4712
Diagnosis Procedure....4712
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4713
Diagnosis Procedure....4713
ECM BRANCH LINE CIRCUIT....4714
Diagnosis Procedure....4714
AFS BRANCH LINE CIRCUIT....4715
Diagnosis Procedure....4715
AV BRANCH LINE CIRCUIT....4716
Diagnosis Procedure....4716
BCM BRANCH LINE CIRCUIT....4717
Diagnosis Procedure....4717
TCM BRANCH LINE CIRCUIT....4718
Diagnosis Procedure....4718
DLC BRANCH LINE CIRCUIT....4719
Diagnosis Procedure....4719
I-KEY BRANCH LINE CIRCUIT....4720
Diagnosis Procedure....4720
M&A BRANCH LINE CIRCUIT....4721
Diagnosis Procedure....4721
STRG BRANCH LINE CIRCUIT....4722
Diagnosis Procedure....4722
TPMS BRANCH LINE CIRCUIT....4723
Diagnosis Procedure....4723
PSB BRANCH LINE CIRCUIT....4724
Diagnosis Procedure....4724
ADP BRANCH LINE CIRCUIT....4725
Diagnosis Procedure....4725
ABS BRANCH LINE CIRCUIT....4726
Diagnosis Procedure....4726
IPDM-E BRANCH LINE CIRCUIT....4727
Diagnosis Procedure....4727
CAN COMMUNICATION CIRCUIT....4728
Diagnosis Procedure....4728
CAN SYSTEM (TYPE 6)....4730
COMPONENT DIAGNOSIS....4730
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4730
Diagnosis Procedure....4730
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4731
Diagnosis Procedure....4731
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4733
Diagnosis Procedure....4733
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4734
Diagnosis Procedure....4734
MAIN LINE BETWEEN ABS AND ICC CIRCUIT....4735
Diagnosis Procedure....4735
ECM BRANCH LINE CIRCUIT....4736
Diagnosis Procedure....4736
AFS BRANCH LINE CIRCUIT....4737
Diagnosis Procedure....4737
AV BRANCH LINE CIRCUIT....4738
Diagnosis Procedure....4738
BCM BRANCH LINE CIRCUIT....4739
Diagnosis Procedure....4739
TCM BRANCH LINE CIRCUIT....4740
Diagnosis Procedure....4740
DLC BRANCH LINE CIRCUIT....4741
Diagnosis Procedure....4741
I-KEY BRANCH LINE CIRCUIT....4742
Diagnosis Procedure....4742
LANE BRANCH LINE CIRCUIT....4743
Diagnosis Procedure....4743
M&A BRANCH LINE CIRCUIT....4744
Diagnosis Procedure....4744
STRG BRANCH LINE CIRCUIT....4745
Diagnosis Procedure....4745
TPMS BRANCH LINE CIRCUIT....4746
Diagnosis Procedure....4746
PSB BRANCH LINE CIRCUIT....4747
Diagnosis Procedure....4747
ADP BRANCH LINE CIRCUIT....4748
Diagnosis Procedure....4748
ABS BRANCH LINE CIRCUIT....4749
Diagnosis Procedure....4749
ICC BRANCH LINE CIRCUIT....4750
Diagnosis Procedure....4750
IPDM-E BRANCH LINE CIRCUIT....4751
Diagnosis Procedure....4751
CAN COMMUNICATION CIRCUIT....4752
Diagnosis Procedure....4752
CAN SYSTEM (TYPE 7)....4754
COMPONENT DIAGNOSIS....4754
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4754
Diagnosis Procedure....4754
MAIN LINE BETWEEN DLC AND RAS CIRCUIT....4755
Diagnosis Procedure....4755
MAIN LINE BETWEEN RAS AND PSB CIRCUIT....4756
Diagnosis Procedure....4756
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4757
Diagnosis Procedure....4757
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4758
Diagnosis Procedure....4758
ECM BRANCH LINE CIRCUIT....4759
Diagnosis Procedure....4759
AFS BRANCH LINE CIRCUIT....4760
Diagnosis Procedure....4760
AV BRANCH LINE CIRCUIT....4761
Diagnosis Procedure....4761
BCM BRANCH LINE CIRCUIT....4762
Diagnosis Procedure....4762
TCM BRANCH LINE CIRCUIT....4763
Diagnosis Procedure....4763
DLC BRANCH LINE CIRCUIT....4764
Diagnosis Procedure....4764
I-KEY BRANCH LINE CIRCUIT....4765
Diagnosis Procedure....4765
M&A BRANCH LINE CIRCUIT....4766
Diagnosis Procedure....4766
STRG BRANCH LINE CIRCUIT....4767
Diagnosis Procedure....4767
TPMS BRANCH LINE CIRCUIT....4768
Diagnosis Procedure....4768
RAS BRANCH LINE CIRCUIT....4769
Diagnosis Procedure....4769
PSB BRANCH LINE CIRCUIT....4770
Diagnosis Procedure....4770
ADP BRANCH LINE CIRCUIT....4771
Diagnosis Procedure....4771
ABS BRANCH LINE CIRCUIT....4772
Diagnosis Procedure....4772
IPDM-E BRANCH LINE CIRCUIT....4773
Diagnosis Procedure....4773
CAN COMMUNICATION CIRCUIT....4774
Diagnosis Procedure....4774
CAN SYSTEM (TYPE 8)....4776
COMPONENT DIAGNOSIS....4776
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4776
Diagnosis Procedure....4776
MAIN LINE BETWEEN DLC AND RAS CIRCUIT....4777
Diagnosis Procedure....4777
MAIN LINE BETWEEN RAS AND PSB CIRCUIT....4778
Diagnosis Procedure....4778
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4779
Diagnosis Procedure....4779
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4780
Diagnosis Procedure....4780
MAIN LINE BETWEEN ABS AND ICC CIRCUIT....4781
Diagnosis Procedure....4781
ECM BRANCH LINE CIRCUIT....4782
Diagnosis Procedure....4782
AFS BRANCH LINE CIRCUIT....4783
Diagnosis Procedure....4783
AV BRANCH LINE CIRCUIT....4784
Diagnosis Procedure....4784
BCM BRANCH LINE CIRCUIT....4785
Diagnosis Procedure....4785
TCM BRANCH LINE CIRCUIT....4786
Diagnosis Procedure....4786
DLC BRANCH LINE CIRCUIT....4787
Diagnosis Procedure....4787
I-KEY BRANCH LINE CIRCUIT....4788
Diagnosis Procedure....4788
LANE BRANCH LINE CIRCUIT....4789
Diagnosis Procedure....4789
M&A BRANCH LINE CIRCUIT....4790
Diagnosis Procedure....4790
STRG BRANCH LINE CIRCUIT....4791
Diagnosis Procedure....4791
TPMS BRANCH LINE CIRCUIT....4792
Diagnosis Procedure....4792
RAS BRANCH LINE CIRCUIT....4793
Diagnosis Procedure....4793
PSB BRANCH LINE CIRCUIT....4794
Diagnosis Procedure....4794
ADP BRANCH LINE CIRCUIT....4795
Diagnosis Procedure....4795
ABS BRANCH LINE CIRCUIT....4796
Diagnosis Procedure....4796
ICC BRANCH LINE CIRCUIT....4797
Diagnosis Procedure....4797
IPDM-E BRANCH LINE CIRCUIT....4798
Diagnosis Procedure....4798
CAN COMMUNICATION CIRCUIT....4799
Diagnosis Procedure....4799
CAN SYSTEM (TYPE 9)....4801
COMPONENT DIAGNOSIS....4801
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4801
Diagnosis Procedure....4801
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4802
Diagnosis Procedure....4802
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4804
Diagnosis Procedure....4804
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4805
Diagnosis Procedure....4805
ECM BRANCH LINE CIRCUIT....4806
Diagnosis Procedure....4806
4WD BRANCH LINE CIRCUIT....4807
Diagnosis Procedure....4807
AFS BRANCH LINE CIRCUIT....4808
Diagnosis Procedure....4808
AV BRANCH LINE CIRCUIT....4809
Diagnosis Procedure....4809
BCM BRANCH LINE CIRCUIT....4810
Diagnosis Procedure....4810
TCM BRANCH LINE CIRCUIT....4811
Diagnosis Procedure....4811
DLC BRANCH LINE CIRCUIT....4812
Diagnosis Procedure....4812
I-KEY BRANCH LINE CIRCUIT....4813
Diagnosis Procedure....4813
M&A BRANCH LINE CIRCUIT....4814
Diagnosis Procedure....4814
STRG BRANCH LINE CIRCUIT....4815
Diagnosis Procedure....4815
TPMS BRANCH LINE CIRCUIT....4816
Diagnosis Procedure....4816
PSB BRANCH LINE CIRCUIT....4817
Diagnosis Procedure....4817
ADP BRANCH LINE CIRCUIT....4818
Diagnosis Procedure....4818
ABS BRANCH LINE CIRCUIT....4819
Diagnosis Procedure....4819
IPDM-E BRANCH LINE CIRCUIT....4820
Diagnosis Procedure....4820
CAN COMMUNICATION CIRCUIT....4821
Diagnosis Procedure....4821
CAN SYSTEM (TYPE 10)....4823
COMPONENT DIAGNOSIS....4823
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4823
Diagnosis Procedure....4823
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4824
Diagnosis Procedure....4824
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4826
Diagnosis Procedure....4826
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4827
Diagnosis Procedure....4827
MAIN LINE BETWEEN ABS AND ICC CIRCUIT....4828
Diagnosis Procedure....4828
ECM BRANCH LINE CIRCUIT....4829
Diagnosis Procedure....4829
4WD BRANCH LINE CIRCUIT....4830
Diagnosis Procedure....4830
AFS BRANCH LINE CIRCUIT....4831
Diagnosis Procedure....4831
AV BRANCH LINE CIRCUIT....4832
Diagnosis Procedure....4832
BCM BRANCH LINE CIRCUIT....4833
Diagnosis Procedure....4833
TCM BRANCH LINE CIRCUIT....4834
Diagnosis Procedure....4834
DLC BRANCH LINE CIRCUIT....4835
Diagnosis Procedure....4835
I-KEY BRANCH LINE CIRCUIT....4836
Diagnosis Procedure....4836
LANE BRANCH LINE CIRCUIT....4837
Diagnosis Procedure....4837
M&A BRANCH LINE CIRCUIT....4838
Diagnosis Procedure....4838
STRG BRANCH LINE CIRCUIT....4839
Diagnosis Procedure....4839
TPMS BRANCH LINE CIRCUIT....4840
Diagnosis Procedure....4840
PSB BRANCH LINE CIRCUIT....4841
Diagnosis Procedure....4841
ADP BRANCH LINE CIRCUIT....4842
Diagnosis Procedure....4842
ABS BRANCH LINE CIRCUIT....4843
Diagnosis Procedure....4843
ICC BRANCH LINE CIRCUIT....4844
Diagnosis Procedure....4844
IPDM-E BRANCH LINE CIRCUIT....4845
Diagnosis Procedure....4845
CAN COMMUNICATION CIRCUIT....4846
Diagnosis Procedure....4846
CAN SYSTEM (TYPE 11)....4848
COMPONENT DIAGNOSIS....4848
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4848
Diagnosis Procedure....4848
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4849
Diagnosis Procedure....4849
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4851
Diagnosis Procedure....4851
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4852
Diagnosis Procedure....4852
ECM BRANCH LINE CIRCUIT....4853
Diagnosis Procedure....4853
4WD BRANCH LINE CIRCUIT....4854
Diagnosis Procedure....4854
AFS BRANCH LINE CIRCUIT....4855
Diagnosis Procedure....4855
AV BRANCH LINE CIRCUIT....4856
Diagnosis Procedure....4856
BCM BRANCH LINE CIRCUIT....4857
Diagnosis Procedure....4857
TCM BRANCH LINE CIRCUIT....4858
Diagnosis Procedure....4858
DLC BRANCH LINE CIRCUIT....4859
Diagnosis Procedure....4859
I-KEY BRANCH LINE CIRCUIT....4860
Diagnosis Procedure....4860
M&A BRANCH LINE CIRCUIT....4861
Diagnosis Procedure....4861
STRG BRANCH LINE CIRCUIT....4862
Diagnosis Procedure....4862
TPMS BRANCH LINE CIRCUIT....4863
Diagnosis Procedure....4863
PSB BRANCH LINE CIRCUIT....4864
Diagnosis Procedure....4864
ADP BRANCH LINE CIRCUIT....4865
Diagnosis Procedure....4865
ABS BRANCH LINE CIRCUIT....4866
Diagnosis Procedure....4866
IPDM-E BRANCH LINE CIRCUIT....4867
Diagnosis Procedure....4867
CAN COMMUNICATION CIRCUIT....4868
Diagnosis Procedure....4868
CAN SYSTEM (TYPE 12)....4870
COMPONENT DIAGNOSIS....4870
MAIN LINE BETWEEN TCM AND DLC CIRCUIT....4870
Diagnosis Procedure....4870
MAIN LINE BETWEEN DLC AND PSB CIRCUIT....4871
Diagnosis Procedure....4871
MAIN LINE BETWEEN PSB AND ADP CIRCUIT....4873
Diagnosis Procedure....4873
MAIN LINE BETWEEN ADP AND ABS CIRCUIT....4874
Diagnosis Procedure....4874
MAIN LINE BETWEEN ABS AND ICC CIRCUIT....4875
Diagnosis Procedure....4875
ECM BRANCH LINE CIRCUIT....4876
Diagnosis Procedure....4876
4WD BRANCH LINE CIRCUIT....4877
Diagnosis Procedure....4877
AFS BRANCH LINE CIRCUIT....4878
Diagnosis Procedure....4878
AV BRANCH LINE CIRCUIT....4879
Diagnosis Procedure....4879
BCM BRANCH LINE CIRCUIT....4880
Diagnosis Procedure....4880
TCM BRANCH LINE CIRCUIT....4881
Diagnosis Procedure....4881
DLC BRANCH LINE CIRCUIT....4882
Diagnosis Procedure....4882
I-KEY BRANCH LINE CIRCUIT....4883
Diagnosis Procedure....4883
LANE BRANCH LINE CIRCUIT....4884
Diagnosis Procedure....4884
M&A BRANCH LINE CIRCUIT....4885
Diagnosis Procedure....4885
STRG BRANCH LINE CIRCUIT....4886
Diagnosis Procedure....4886
TPMS BRANCH LINE CIRCUIT....4887
Diagnosis Procedure....4887
PSB BRANCH LINE CIRCUIT....4888
Diagnosis Procedure....4888
ADP BRANCH LINE CIRCUIT....4889
Diagnosis Procedure....4889
ABS BRANCH LINE CIRCUIT....4890
Diagnosis Procedure....4890
ICC BRANCH LINE CIRCUIT....4891
Diagnosis Procedure....4891
IPDM-E BRANCH LINE CIRCUIT....4892
Diagnosis Procedure....4892
CAN COMMUNICATION CIRCUIT....4893
Diagnosis Procedure....4893
lt....4895
Table of Contents....4895
SERVICE INFORMATION....4898
DTC INDEX....4898
U1000-U1010....4898
B2503-B2521....4898
PRECAUTIONS....4899
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....4899
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....4899
Precautions For Xenon Headlamp Service....4899
HEADLAMP (FOR USA) - XENON TYPE -....4900
Component Parts and Harness Connector Location....4900
System Description....4900
OUTLINE....4900
HEADLAMP OPERATION....4901
Low Beam Operation....4901
High Beam Operation/Flash-to-Pass Operation....4901
COMBINATION SWITCH READING FUNCTION....4902
EXTERIOR LAMP BATTERY SAVER CONTROL....4902
AUTO LIGHT OPERATION....4902
XENON HEADLAMP....4902
CAN Communication System Description....4902
CAN Communication Unit....4902
Schematic....4903
Wiring Diagram - H/LAMP -....4904
Terminal and Reference Value for BCM....4909
Terminal and Reference Value for IPDM E/R....4911
How to Perform Trouble Diagnosis....4912
Preliminary Check....4912
CHECK POWER SUPPLY AND GROUND CIRCUIT....4912
CONSULT-III Functions (BCM - HEAD LAMP)....4913
DATA MONITOR....4913
Display Item List....4913
ACTIVE TEST....4914
Display Item List....4914
CONSULT-III Functions (IPDM E/R)....4914
DATA MONITOR....4915
All Signals, Main Signals, Selection From Menu....4915
ACTIVE TEST....4915
Headlamp High Beam Does Not Illuminate (Both Sides)....4915
Headlamp High Beam Does Not Illuminate (One Side)....4917
High Beam Indicator Lamp Does Not Illuminate....4919
Headlamp Low Beam Does Not Illuminate (Both Sides)....4919
Headlamp Low Beam Does Not Illuminate (One Side)....4921
Headlamps Do Not Turn OFF....4923
General Information for Xenon Headlamp Trouble Diagnosis....4923
Caution:....4923
Xenon Headlamp Trouble Diagnosis....4924
Aiming Adjustment....4924
PREPARATION BEFORE ADJUSTING....4925
LOW BEAM AND HIGH BEAM....4925
ADJUSTMENT USING AN ADJUSTMENT SCREEN (LIGHT/DARK BORDERLINE)....4925
Bulb Replacement....4925
HEADLAMP (INNER) HIGH BEAM ....4925
HEADLAMP (OUTER) LOW BEAM....4926
PARKING LAMP....4926
FRONT TURN SIGNAL LAMP....4926
FRONT SIDE MARKER LAMP....4926
Removal and Installation....4927
REMOVAL....4927
INSTALLATION....4927
Disassembly and Assembly....4927
DISASSEMBLY....4928
ASSEMBLY....4928
HEADLAMP (FOR CANADA) - DAYTIME LIGHT SYSTEM -....4929
Component Parts and Harness Connector Location....4929
System Description....4929
OUTLINE....4929
HEADLAMP OPERATION....4930
Low Beam Operation....4930
High Beam Operation (When Daytime Light Does Not Operate)/Flash-to-Pass Operation....4930
DAYTIME LIGHT OPERATION....4931
COMBINATION SWITCH READING FUNCTION....4931
AUTO LIGHT OPERATION....4931
CAN Communication System Description....4931
CAN Communication Unit....4931
Schematic....4932
Wiring Diagram - DTRL -....4933
Terminal and Reference Value for BCM....4938
Terminal and Reference Value for IPDM E/R....4940
How to Perform Trouble Diagnosis....4941
Preliminary Check....4941
INSPECTION FOR POWER SUPPLY AND GROUND CIRCUIT....4941
INSPECTION FOR PARKING BRAKE SWITCH CIRCUIT....4942
CONSULT-III Functions (BCM - HEAD LAMP)....4943
DATA MONITOR....4943
Display Item List....4943
ACTIVE TEST....4944
Display Item List....4944
CONSULT-III Functions (IPDM E/R)....4944
DATA MONITOR....4944
All Signals, Main Signals, Selection From Menu....4944
ACTIVE TEST....4944
Daytime Light Control Does Not Operate Properly (Normal Headlamps Operate Properly)....4945
Headlamp High Beam Does Not Illuminate (Both Sides)....4947
RH High Beam Does Not Illuminate But LH High Beam Illuminates....4950
LH High Beam Does Not Illuminate But RH High Beam Illuminates....4951
Headlamp Low Beam Does Not Illuminate (Both Sides)....4953
Headlamp Low Beam Does Not Illuminate (One Side)....4955
Headlamps Do Not Turn OFF....4956
General Information for Xenon Headlamp Trouble Diagnosis....4957
Caution....4957
Xenon Headlamp Trouble Diagnosis....4957
Aiming Adjustment....4958
Bulb Replacement....4958
Removal and Installation....4958
Disassembly and Assembly....4958
AUTO LIGHT SYSTEM....4959
Component Parts and Harness Connector Location....4959
System Description....4959
OUTLINE....4959
COMBINATION SWITCH READING FUNCTION....4959
EXTERIOR LAMP BATTERY SAVER CONTROL....4959
DELAY TIMER FUNCTION....4960
CAN Communication System Description....4960
CAN Communication Unit....4960
Major Component and Functions....4960
Schematic....4961
Wiring Diagram - AUTO/L -....4962
Terminal and Reference Value for BCM....4966
Terminal and Reference Value for IPDM E/R....4969
How to Perform Trouble Diagnosis....4969
Preliminary Check....4969
SETTING CHANGE FUNCTIONS....4969
CHECK POWER SUPPLY AND GROUND CIRCUIT....4969
CONSULT-III Functions (BCM - HEAD LAMP)....4970
WORK SUPPORT....4971
Work Support Setting Item....4971
DATA MONITOR....4971
Display Item List....4971
ACTIVE TEST....4972
Display Item List....4972
Symptom Chart....4972
Lighting Switch Inspection....4972
Optical Sensor System Inspection....4973
Removal and Installation for Optical Sensor....4974
REMOVAL....4974
INSTALLATION....4975
ACTIVE AFS....4976
Component Parts and Harness Connector Location....4976
System Description....4976
AFS (ADAPTIVE FRONT-LIGHTING SYSTEM)....4977
HEADLAMP AUTO AIMING....4977
OUTLINE....4978
AFS OPERATION....4978
When The Steering Wheel Is Turned To The Left....4978
When The Steering Wheel Is Turned To The Right....4979
AFS OFF INDICATOR OPERATION....4979
SWIVEL ACTUATOR INITIALIZATION....4980
HEADLAMP AUTO AIMING OPERATION ....4980
Auto Aiming Operation....4980
CAN COMMUNICATION SYSTEM DESCRIPTION....4980
CAN COMMUNICATION UNIT....4980
Component Parts Description....4981
AFS CONTROL UNIT....4981
SWIVEL ACTUATOR....4981
AIMING MOTOR....4981
AFS SWITCH....4982
HEIGHT SENSOR....4982
STEERING ANGLE SENSOR....4982
IPDM E/R....4982
ECM....4982
TCM....4982
UNIFIED METER AND A/C AMP...4982
COMBINATION METER....4982
Schematic....4983
Wiring Diagram - AFS -....4984
Terminal and Reference Value for AFS Control Unit....4991
How to Proceed with Trouble Diagnosis....4992
Preliminary Check....4992
CONSULT-III Function (ADAPTIVE LIGHT)....4993
WORK SUPPORT (STEERING ANGLE SENSOR ADJUSTMENT)....4993
Work Support Item List....4993
Notes on Steering Angle Sensor (Neutral Point) Adjustment....4994
Operation Procedure....4994
WORK SUPPORT (LEVELIZER ADJUSTMENT)....4994
Work Support Item List....4994
SELF-DIAG RESULTS....4994
Description of DTC and Solutions after Detection....4994
DATA MONITOR....4997
Data Monitor item....4997
ACTIVE TEST....4998
Symptom Chart....4999
DTC U1000 CAN COMM CIRCUIT....5000
DTC U1010 CONTROL UNIT (CAN)....5001
DTC B2503 SWIVEL ACTUATOR RH....5001
DTC B2504 SWIVEL ACTUATOR LH....5006
DTC B2514 HI SEN UNUSUAL RR....5011
DTC C0126 ST ANG SEN SIG....5014
DTC B2516 SIFT SIG [P,R]....5014
DTC B2517 VEHICLE SPEED SIG....5015
DTC B2519 LEVELIZER CALIB....5015
DTC C0428 ST ANGLE SEN CALIB....5015
DTC B2521 ECU CIRC....5015
AFS Operation Check (Function Test)....5018
Auto Aiming Operation Check (Function Test)....5019
AFS Switch Does Not Operate....5021
Auto Aiming Does Not Operate (Check Aiming Motor System Circuit)....5023
AFS OFF Indicator Does Not Operate....5026
Removal and Installation of Steering Angle Sensor....5026
Removal and Installation of Front Combination Lamp....5026
Removal and Installation of AFS Control Unit....5026
REMOVAL....5026
INSTALLATION....5026
Removal and Installation of AFS Switch....5027
REMOVAL....5027
INSTALLATION....5027
Removal and Installation of Height Sensor....5027
REMOVAL....5027
INSTALLATION....5028
FRONT FOG LAMP....5029
Component Parts and Harness Connector Location....5029
System Description....5029
OUTLINE....5029
FOG LAMP OPERATION....5030
COMBINATION SWITCH READING FUNCTION....5030
EXTERIOR LAMP BATTERY SAVER CONTROL....5030
CAN Communication System Description....5030
CAN Communication Unit....5031
Schematic....5031
Wiring Diagram - F/FOG -....5032
Terminal and Reference Value for BCM....5035
Terminal and Reference Value for IPDM E/R....5037
How to Perform Trouble Diagnosis....5037
Preliminary Check....5037
CHECK POWER SUPPLY AND GROUND CIRCUIT....5037
CONSULT-III Functions (BCM - HEAD LAMP)....5038
CONSULT-III Functions (IPDM E/R)....5038
Front Fog Lamps Do Not Illuminate (Both Sides)....5038
Front Fog Lamp Does Not Illuminate (One Side)....5040
Front Fog Lamps Do Not Turn OFF....5041
Aiming Adjustment....5042
Bulb Replacement....5043
STANDARD TYPE....5043
STANDARD TYPE : Removal and Installation....5044
REMOVAL....5044
INSTALLATION....5044
SPORTS TYPE....5044
SPORTS TYPE : Removal and Installation....5044
REMOVAL....5044
INSTALLATION....5045
TURN SIGNAL AND HAZARD WARNING LAMPS....5046
Component Parts and Harness Connector Location....5046
System Description....5046
TURN SIGNAL OPERATION....5046
LH Turn Signal Lamp....5046
RH Turn Signal Lamp....5047
HAZARD LAMP OPERATION....5047
COMBINATION SWITCH READING FUNCTION....5048
CAN Communication System Description....5048
CAN Communication Unit....5048
Schematic....5049
Wiring Diagram - TURN -....5050
Terminal and Reference Value for BCM....5053
How to Perform Trouble Diagnosis....5055
Preliminary Check....5055
CHECK POWER SUPPLY AND GROUND CIRCUIT....5055
CONSULT-III Functions (BCM - FLASHER)....5056
DATA MONITOR....5056
Display Item List....5056
ACTIVE TEST....5056
Display Item List....5056
Turn Signal Lamp Does Not Operate....5057
Hazard Warning Lamp Does Not Operate But Turn Signal Lamp Operates....5058
Turn Signal Indicator Lamp Does Not Operate....5059
Bulb Replacement (Front Turn Signal Lamp)....5060
Bulb Replacement (Side Turn Signal Lamp)....5060
Bulb Replacement....5060
Bulb Replacement (Rear Turn Signal Lamp)....5060
Removal and Installation of Front Turn Signal Lamp....5060
Removal and Installation of Side Turn Signal Lamp....5060
REMOVAL....5060
INSTALLATION....5060
Removal and Installation of Rear Turn Signal Lamp....5061
LIGHTING AND TURN SIGNAL SWITCH....5062
Removal and Installation....5062
REMOVAL....5062
INSTALLATION....5062
Switch Circuit Inspection....5062
HAZARD SWITCH....5063
Removal and Installation....5063
REMOVAL....5063
COMBINATION SWITCH....5064
Wiring Diagram - COMB SW -....5064
Combination Switch Reading Function....5064
Terminal and Reference Value for BCM....5065
CONSULT-III Functions (BCM - COMB SW)....5068
DATA MONITOR....5068
Display Item List....5068
Combination Switch Inspection....5069
Removal and Installation....5071
STOP LAMP....5072
Wiring Diagram - STOP LAMP -....5072
High-Mounted Stop Lamp....5073
BULB REPLACEMENT, REMOVAL AND INSTALLATION....5073
Stop Lamp....5074
BULB REPLACEMENT ....5074
REMOVAL AND INSTALLATION....5074
BACK-UP LAMP....5075
Wiring Diagram - B/LAMP -....5075
Bulb Replacement....5075
Removal and Installation....5076
REMOVAL....5076
INSTALLATION....5076
PARKING, LICENSE PLATE AND TAIL LAMPS....5077
Component Parts and Harness Connector Location....5077
System Description....5077
OUTLINE....5077
OPERATION BY LIGHTING SWITCH....5078
COMBINATION SWITCH READING FUNCTION....5078
EXTERIOR LAMP BATTERY SAVER CONTROL....5078
CAN Communication System Description....5078
CAN Communication Unit....5078
Schematic....5079
Wiring Diagram - TAIL/L -....5080
Terminal and Reference Value for BCM....5085
Terminal and Reference Value for IPDM E/R....5086
How to Perform Trouble Diagnosis....5087
Preliminary Check....5087
CHECK POWER SUPPLY AND GROUND CIRCUIT....5087
CONSULT-III Functions (BCM - HEAD LAMP)....5088
CONSULT-III Functions (IPDM E/R)....5088
Parking, License Plate and Tail Lamps Do Not Illuminate....5088
Parking, License Plate and Tail Lamps Do Not Turn OFF (After Approx. 10 Minutes)....5092
License Plate Lamp....5092
BULB REPLACEMENT....5092
Removal and Installation....5092
REMOVAL....5092
INSTALLATION....5093
Parking Lamp....5093
BULB REPLACEMENT....5093
REMOVAL AND INSTALLATION....5093
REAR COMBINATION LAMP....5094
Bulb Replacement....5094
REAR TURN SIGNAL LAMP BULB....5094
STOP/TAIL LAMP....5094
Removal and Installation....5094
REMOVAL....5094
INSTALLATION....5095
INTERIOR ROOM LAMP....5096
Component Parts and Harness Connector Location....5096
System Description....5096
ROOM LAMP TIMER BASIC OPERATION....5096
POWER SUPPLY AND GROUND....5097
SWITCH OPERATION....5097
ROOM LAMP TIMER OPERATION....5098
ROOM LAMP TIMER OPERATING TIME....5099
CONDITIONS FOR CANCELING TIMER....5099
ROOM LAMP TIMER INAPPLICABLE LAMPS OPERATION....5099
INTERIOR ROOM LAMP BATTERY SAVER FUNCTION....5099
Schematic....5101
Wiring Diagram - ROOM/L -....5103
Terminal and Reference Value for BCM....5110
How to Perform Trouble Diagnosis....5111
Preliminary Check....5111
CHECK POWER SUPPLY AND GROUND CIRCUIT....5111
CONSULT-III Functions (BCM - INT LAMP)....5112
WORK SUPPORT....5112
Display Item List....5112
DATA MONITOR....5113
Display Item List....5113
ACTIVE TEST....5114
Display Item List....5114
CONSULT-III Functions (BCM - BATTERY SAVER)....5114
WORK SUPPORT....5114
Display Item List....5114
DATA MONITOR....5114
Display Item List....5114
ACTIVE TEST....5115
Display Item List....5115
Interior Room Lamp Control Does Not Operate....5115
Map Lamp....5116
BULB REPLACEMENT....5116
REMOVAL AND INSTALLATION....5116
Personal Lamp....5116
BULB REPLACEMENT....5116
REMOVAL AND INSTALLATION....5117
Removal....5117
Installation....5117
Foot Lamp (Driver Side)....5117
BULB REPLACEMENT....5117
REMOVAL AND INSTALLATION....5117
Removal....5117
Installation....5117
Foot Lamp (Passenger Side)....5117
BULB REPLACEMENT....5117
REMOVAL AND INSTALLATION....5118
Removal....5118
Installation....5118
Vanity Mirror Lamp....5118
BULB REPLACEMENT....5118
Step Lamp....5118
BULB REPLACEMENT....5118
REMOVAL AND INSTALLATION....5119
Kicking Plate Illumination....5119
BULB REPLACEMENT....5119
REMOVAL AND INSTALLATION....5119
Trunk Room Lamp (Upper/Lower)....5119
BULB REPLACEMENT....5119
REMOVAL AND INSTALLATION....5119
Removal....5119
Installation....5119
ILLUMINATION....5120
System Description....5120
OUTLINE....5120
ILLUMINATION OPERATION BY LIGHTING SWITCH....5120
EXTERIOR LAMP BATTERY SAVER CONTROL....5122
CAN Communication System Description....5122
CAN Communication Unit....5122
Schematic....5123
Wiring Diagram - ILL -....5125
Glove Box Lamp....5137
BULB REPLACEMENT, REMOVAL AND INSTALLATION....5137
Removal....5137
Installation....5138
Cigarette Lighter Illumination....5138
BULB REPLACEMENT, REMOVAL AND INSTALLATION....5138
Removal....5138
Installation....5138
Front Ashtray Illumination....5138
BULB REPLACEMENT, REMOVAL AND INSTALLATION....5138
Rear Ashtray Illumination....5138
REMOVAL AND INSTALLATION....5138
INSTALLATION....5139
BULB SPECIFICATIONS....5140
Headlamp....5140
Exterior Lamp....5140
Interior Lamp/Illumination....5140
lu....5141
Table of Contents....5141
VQ35HR....5142
SERVICE INFORMATION....5142
PRECAUTIONS....5142
Precaution for Liquid Gasket....5142
LIQUID GASKET APPLICATION PROCEDURE....5142
PREPARATION....5143
Special Service Tool....5143
Commercial Service Tool....5143
LUBRICATION SYSTEM....5144
Lubrication Circuit....5144
System Chart....5144
ENGINE OIL....5145
Inspection....5145
ENGINE OIL LEVEL....5145
ENGINE OIL APPEARANCE....5145
ENGINE OIL LEAKAGE....5145
OIL PRESSURE CHECK....5145
Changing Engine Oil....5147
OIL FILTER....5148
Removal and Installation....5148
REMOVAL....5148
INSTALLATION....5148
INSPECTION AFTER INSTALLATION....5149
OIL FILTER BRACKET (AWD)....5150
Component....5150
Removal and Installation....5150
REMOVAL....5150
INSTALLATION....5150
INSPECTION AFTER INSTALLATION....5151
OIL COOLER....5152
Component....5152
Removal and Installation....5153
REMOVAL....5153
INSPECTION AFTER REMOVAL....5154
Oil Cooler....5154
Relief Valve....5154
INSTALLATION....5154
2WD Models....5154
AWD Models....5154
INSPECTION AFTER INSTALLATION....5154
OIL PUMP....5156
Component....5156
Removal and Installation....5156
REMOVAL....5156
INSTALLATION....5156
INSPECTION AFTER INSTALLATION....5156
Disassembly and Assembly....5156
DISASSEMBLY....5156
INSPECTION AFTER DISASSEMBLY....5156
Oil Pump Clearance....5157
Regulator Valve Clearance....5157
ASSEMBLY....5158
SERVICE DATA AND SPECIFICATIONS (SDS)....5159
Standard and Limit....5159
ENGINE OIL PRESSURE....5159
ENGINE OIL CAPACITY (APPROXIMATE)....5159
OIL PUMP....5159
REGULATOR VALVE....5159
VK45DE....5160
SERVICE INFORMATION....5160
PRECAUTIONS....5160
Precaution for Liquid Gasket....5160
LIQUID GASKET APPLICATION PROCEDURE....5160
PREPARATION....5161
Special Service Tool....5161
Commercial Service Tool....5161
LUBRICATION SYSTEM....5162
Lubrication Circuit....5162
System Chart....5163
ENGINE OIL....5164
Inspection....5164
ENGINE OIL LEVEL....5164
ENGINE OIL APPEARANCE....5164
ENGINE OIL LEAKAGE....5164
OIL PRESSURE CHECK....5164
Changing Engine Oil....5165
OIL FILTER....5167
Removal and Installation....5167
REMOVAL....5167
INSTALLATION....5167
INSPECTION AFTER INSTALLATION....5167
OIL PUMP....5168
Component....5168
Removal and Installation....5168
REMOVAL....5168
INSTALLATION....5168
INSPECTION AFTER INSTALLATION....5169
Disassembly and Assembly....5169
DISASSEMBLY....5169
INSPECTION AFTER DISASSEMBLY ....5169
Oil Pump Clearance....5169
Regulator Valve Clearance....5170
ASSEMBLY....5170
SERVICE DATA AND SPECIFICATIONS (SDS)....5171
Standard and Limit....5171
ENGINE OIL PRESSURE....5171
ENGINE OIL CAPACITY (APPROXIMATE)....5171
OIL PUMP....5171
REGULATOR VALVE....5171
ma....5172
Table of Contents....5172
SERVICE INFORMATION....5173
PREPARATION....5173
Special Service Tool....5173
Commercial Service Tool....5173
GENERAL MAINTENANCE....5174
Explanation of General Maintenance....5174
PERIODIC MAINTENANCE....5176
Introduction of Periodic Maintenance....5176
Schedule 1....5176
EMISSION CONTROL SYSTEM MAINTENANCE....5176
CHASSIS AND BODY MAINTENANCE....5177
Schedule 2....5178
EMISSION CONTROL SYSTEM MAINTENANCE....5178
CHASSIS AND BODY MAINTENANCE....5179
RECOMMENDED FLUIDS AND LUBRICANTS....5180
Fluids and Lubricants....5180
Engine Oil Recommendation....5181
Anti-Freeze Coolant Mixture Ratio....5181
ENGINE MAINTENANCE (VQ35HR)....5182
Checking Drive Belt....5182
Tension Adjustment....5182
Changing Engine Coolant....5182
DRAINING ENGINE COOLANT....5182
REFILLING ENGINE COOLANT....5183
FLUSHING COOLING SYSTEM....5184
Checking Fuel Line....5185
Changing Air Cleaner Filter....5185
VISCOUS PAPER TYPE....5185
Changing Engine Oil....5185
Changing Oil Filter....5186
REMOVAL....5186
INSTALLATION....5187
INSPECTION AFTER INSTALLATION....5187
Changing Spark Plugs (Iridium-Tipped Type)....5187
REMOVAL....5187
INSPECTION AFTER REMOVAL....5188
INSTALLATION....5188
Checking EVAP Vapor Line....5188
ENGINE MAINTENANCE (VK45DE)....5189
Checking Drive Belts....5189
Tension Adjustment....5189
Changing Engine Coolant....5189
DRAINING ENGINE COOLANT....5189
REFILLING ENGINE COOLANT....5190
FLUSHING COOLING SYSTEM....5191
Checking Fuel Line....5192
Changing Air Cleaner Filter....5192
VISCOUS PAPER TYPE....5192
Changing Engine Oil....5192
Changing Oil Filter....5193
REMOVAL....5193
INSTALLATION....5193
INSPECTION AFTER INSTALLATION....5194
Changing Spark Plugs (Platinum-Tipped Type)....5194
REMOVAL....5194
INSPECTION AFTER REMOVAL....5194
INSTALLATION....5195
Checking EVAP Vapor Line....5195
CHASSIS AND BODY MAINTENANCE....5196
Checking Exhaust System....5196
Checking A/T Fluid (5A/T)....5196
Changing A/T Fluid (5A/T)....5197
Checking Transfer Fluid....5198
Changing Transfer Fluid....5198
Checking Propeller Shaft....5199
Checking Differential Gear Oil....5199
Changing Differential Gear Oil....5199
Balancing Wheels (Bonding Weight Type)....5200
REMOVAL....5200
WHEEL BALANCE ADJUSTMENT ....5200
Rotation....5202
Checking Brake Fluid Level and Leaks....5202
Checking Brake Line and Cables....5202
Changing Brake Fluid....5202
Checking Disc Brake....5203
ROTOR....5203
CALIPER....5203
PAD....5203
Checking Steering Gear and Linkage....5203
STEERING GEAR....5203
STEERING LINKAGE....5203
Checking Power Steering Fluid and Line....5204
Axle and Suspension Parts....5204
Drive Shaft....5205
Lubricating Locks, Hinges and Hood Latch....5205
Checking Seat Belt, Buckles, Retractors, Anchors and Adjusters....5206
SERVICE DATA AND SPECIFICATIONS (SDS)....5207
Standard and Limit....5207
BELT DEFLECTION AND TENSION (VQ35HR)....5207
BELT DEFLECTION AND TENSION (VK45DE)....5207
ENGINE COOLANT CAPACITY (APPROXIMATE) (VQ35HR)....5207
ENGINE COOLANT CAPACITY (APPROXIMATE) (VK45DE)....5207
RADIATOR (VQ35HR)....5207
RADIATOR (VK45DE)....5207
ENGINE OIL CAPACITY (APPROXIMATE) (VQ35HR)....5207
ENGINE OIL CAPACITY (APPROXIMATE) (VK45DE)....5207
SPARK PLUG (PLATINUM-TIPPED TYPE) (VQ35HR)....5207
SPARK PLUG (PLATINUM-TIPPED TYPE) (VK45DE)....5207
WHEEL BALANCE....5208
pb....5209
Table of Contents....5209
SERVICE INFORMATION....5210
PREPARATION....5210
Commercial Service Tool....5210
PARKING BRAKE SYSTEM....5211
On-Vehicle Service....5211
PEDAL STROKE....5211
INSPECT COMPONENTS....5211
ADJUSTMENT....5211
PARKING BRAKE CONTROL....5212
Component....5212
Removal and Installation....5212
REMOVAL....5212
INSTALLATION....5212
PARKING BRAKE SHOE....5214
Component....5214
Removal and Installation....5214
REMOVAL....5214
INSPECTION AFTER REMOVAL....5215
Lining Thickness Inspection....5215
Drum Inner Diameter Inspection....5215
Other Inspections....5215
INSTALLATION....5215
SERVICE DATA AND SPECIFICATIONS (SDS)....5217
Parking Drum Brake....5217
Parking Brake Control....5217
pg....5218
Table of Contents....5218
SERVICE INFORMATION....5219
DTC INDEX....5219
U1000....5219
PRECAUTIONS....5220
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5220
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5220
Precaution for Procedure without Cowl Top Cover....5220
POWER SUPPLY ROUTING CIRCUIT....5221
Schematic....5221
Wiring Diagram - POWER -....5223
BATTERY POWER SUPPLY - IGNITION SW. IN ANY POSITION ....5223
ACCESSORY POWER SUPPLY - IGNITION SW. IN “ACC” OR “ON”....5229
IGNITION POWER SUPPLY - IGNITION SW. IN “ON” AND/OR “START”....5230
Fuse....5235
Fusible Link....5235
Circuit Breaker....5235
IPDM E/R (INTELLIGENT POWER DISTRIBUTION MODULE ENGINE ROOM)....5236
System Description....5236
SYSTEMS CONTROLLED BY IPDM E/R....5236
CAN COMMUNICATION LINE CONTROL....5236
IPDM E/R STATUS CONTROL....5237
CAN Communication System Description....5237
CAN Communication Unit....5237
Function of Detecting Ignition Relay Malfunction....5237
CONSULT-III Function (IPDM E/R)....5237
SELF-DIAGNOSTIC RESULT....5238
DATA MONITOR....5238
ACTIVE TEST....5238
Auto Active Test....5239
DESCRIPTION....5239
OPERATION PROCEDURE....5239
INSPECTION IN AUTO ACTIVE TEST MODE....5239
Concept of Auto Active Test....5240
Schematic....5242
IPDM E/R Terminal Arrangement....5243
Check IPDM E/R Power Supply and Ground Circuit....5243
U1000 CAN COMM CIRCUIT....5244
Removal and Installation of IPDM E/R....5244
REMOVAL ....5244
INSTALLATION....5245
PDU (POWER DISTRIBUTION UNIT)....5246
Component Parts and Harness Connector Location....5246
System Description....5246
PUSH-BUTTON IGNITION SWITCH OPERATING PROCEDURE....5246
Wiring Diagram - PDU -....5248
Terminal and Reference Value for Intelligent Key Unit....5250
Terminal and Reference Value for PDU....5251
Work Flow....5251
Trouble Diagnosis Symptom Chart....5252
Check CAN Communication System....5252
Check PDU Power Supply and Ground Circuit....5252
Check Push-Button Ignition Switch (Ignition Switch) System....5253
Check Push-Button Ignition Switch (Indicator Circuit) System....5254
PDU Communication Circuit System 1....5255
PDU Communication Circuit System 2....5256
Removal and Installation of PDU....5257
REMOVAL....5257
INSTALLATION....5257
HARNESS....5258
Harness Layout....5258
HOW TO READ HARNESS LAYOUT....5258
To Use the Grid Reference....5258
OUTLINE....5259
MAIN HARNESS....5259
Instrument Panel....5260
Floor Console....5263
Roof....5264
NAVIGATION SUB-HARNESS & A/C HARNESS....5265
ENGINE ROOM HARNESS....5265
Engine Compartment....5266
Passenger Compartment....5269
Battery Cable (With VQ Engine)....5270
Battery Cable (2WD Models with VK Engine)....5271
Battery Cable (AWD Models with VK Engine)....5272
ENGINE CONTROL HARNESS (VQ ENGINE)....5272
Engine Compartment....5273
Passenger Compartment....5275
ENGINE CONTROL HARNESS (VK ENGINE)....5275
Engine Compartment....5276
Passenger Compartment....5278
BODY HARNESS....5278
Passenger Compartment....5279
Luggage Compartment....5281
BODY NO. 2 HARNESS....5282
Passenger Compartment....5283
Luggage Compartment....5285
TAIL HARNESS....5287
ROOM LAMP HARNESS ....5288
FRONT DOOR HARNESS ....5288
LH Side....5289
RH Side....5289
REAR DOOR HARNESS....5289
LH Side....5290
RH Side....5290
HARNESS CONNECTOR....5291
Description....5291
HARNESS CONNECTOR (TAB-LOCKING TYPE)....5291
HARNESS CONNECTOR (SLIDE-LOCKING TYPE)....5291
HARNESS CONNECTOR (LEVER LOCKING TYPE)....5292
ELECTRICAL UNITS....5294
Terminal Arrangement....5294
SMJ (SUPER MULTIPLE JUNCTION)....5296
Terminal Arrangement....5296
STANDARDIZED RELAY....5299
Description....5299
NORMAL OPEN, NORMAL CLOSED AND MIXED TYPE RELAYS....5299
TYPE OF STANDARDIZED RELAYS....5299
FUSE BLOCK - JUNCTION BOX (J/B)....5301
Terminal Arrangement....5301
FUSE, FUSIBLE LINK AND RELAY BOX....5302
Terminal Arrangement....5302
pr....5303
Table of Contents....5303
SERVICE INFORMATION....5304
PREPARATION....5304
Commercial Service Tool....5304
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....5305
NVH Troubleshooting Chart....5305
FRONT PROPELLER SHAFT....5306
On-Vehicle Inspection....5306
APPEARANCE AND NOISE INSPECTION....5306
PROPELLER SHAFT VIBRATION....5306
Propeller Shaft Runout Measuring Point....5306
Component....5306
Removal and Installation....5307
REMOVAL....5307
INSPECTION....5307
INSTALLATION....5307
REAR PROPELLER SHAFT....5309
On-Vehicle Inspection....5309
APPEARANCE AND NOISE INSPECTION....5309
PROPELLER SHAFT VIBRATION....5309
Propeller Shaft Runout Measuring Point....5309
Component....5310
Removal and Installation....5311
REMOVAL....5311
INSPECTION....5312
INSTALLATION....5312
SERVICE DATA AND SPECIFICATIONS (SDS)....5314
General Specification....5314
2WD MODELS....5314
AWD MODELS....5314
Journal Axial Play....5315
Propeller Shaft Runout....5315
ps....5316
Table of Contents....5316
SERVICE INFORMATION....5317
PRECAUTIONS....5317
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5317
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5317
Precaution Necessary for Steering Wheel Rotation After Battery Disconnect....5317
OPERATION PROCEDURE....5317
Precaution for Steering System....5318
PREPARATION....5319
Special Service Tools....5319
Commercial Service Tool....5320
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....5321
NVH Troubleshooting Chart....5321
POWER STEERING FLUID....5322
Checking Fluid Level....5322
Checking Fluid Leakage....5322
Air Bleeding Hydraulic System....5322
STEERING WHEEL....5324
On-Vehicle Inspection and Service....5324
CHECKING CONDITION OF INSTALLATION....5324
CHECKING STEERING WHEEL PLAY....5324
CHECKING NEUTRAL POSITION STEERING WHEEL....5324
CHECKING STEERING WHEEL TURNING FORCE....5324
CHECKING FRONT WHEEL TURNING ANGLE....5325
Removal and Installation....5325
REMOVAL....5325
INSTALLATION....5326
STEERING COLUMN....5327
Removal and Installation....5327
COMPONENTS....5327
REMOVAL OF UPPER JOINT, COLLAR, HOLE COVER SEAL, HOLE COVER, LOWER SHAFT AND LOWER JOINT ....5327
INSPECTION AFTER REMOVAL....5328
INSTALLATION OF UPPER JOINT, COLLAR, HOLE COVER SEAL, HOLE COVER, LOWER SHAFT AND LOWER JOINT....5328
REMOVAL OF STEERING COLUMN ASSEMBLY....5329
INSPECTION AFTER REMOVAL....5329
INSTALLATION OF STEERING COLUMN ASSEMBLY....5330
INSPECTION AFTER INSTALLATION....5330
Disassembly and Assembly....5330
COMPONENTS....5330
DISASSEMBLY....5331
INSPECTION AFTER DISASSEMBLY....5331
ASSEMBLY....5331
INSPECTION AFTER ASSEMBLY....5331
POWER STEERING GEAR AND LINKAGE....5333
Removal and Installation....5333
COMPONENTS....5333
REMOVAL....5333
INSTALLATION....5334
INSPECTION AFTER INSTALLATION....5334
Disassembly and Assembly....5334
COMPONENTS....5334
DISASSEMBLY....5335
INSPECTION AFTER DISASSEMBLY....5337
Boot....5337
Rack Assembly....5337
Gear-Sub Assembly....5337
Gear Housing Assembly....5337
Outer Socket and Inner Socket....5337
ASSEMBLY....5338
POWER STEERING OIL PUMP....5343
On-Vehicle Inspection and Service....5343
CHECKING RELIEF OIL PRESSURE....5343
Removal and Installation....5343
REMOVAL....5343
INSTALLATION....5343
Disassembly and Assembly (Models with VK45DE)....5343
COMPONENTS....5343
INSPECTION BEFORE DISASSEMBLY....5344
DISASSEMBLY....5344
INSPECTION AFTER DISASSEMBLY....5345
Body Assembly and Rear Cover Inspection....5345
Cartridge Assembly Inspection....5345
Side Plate Inspection....5345
Flow Control Valve Inspection....5345
ASSEMBLY....5345
Disassembly and Assembly (Models with VQ35HR)....5347
COMPONENTS....5347
INSPECTION BEFORE DISASSEMBLY....5348
DISASSEMBLY....5348
INSPECTION AFTER DISASSEMBLY....5348
Body Assembly and Rear Cover Inspection....5348
Cartridge Assembly Inspection....5348
Side Plate Inspection....5348
Flow Control Valve Inspection....5348
ASSEMBLY....5348
HYDRAULIC LINE....5351
Removal and Installation....5351
COMPONENTS (VQ35HR 2WD MODELS)....5351
COMPONENTS (VQ35HR AWD MODELS)....5352
COMPONENTS (VK45DE 2WD MODELS)....5353
COMPONENTS (VK45DE AWD MODELS)....5354
REMOVAL AND INSTALLATION....5355
SERVICE DATA AND SPECIFICATIONS (SDS)....5356
Steering Wheel....5356
Steering Angle....5356
Steering Column....5356
STEERING COLUMN LENGTH....5356
TILT AND TELESCOPIC MECHANISM OPERATING RANGE....5356
Lower Shaft ....5356
Steering Gear....5356
STEERING OUTER SOCKET AND INNER SOCKET....5356
RACK STROKE....5357
RACK SLIDING FORCE....5357
Oil Pump....5357
Steering Fluid....5357
rax....5358
Table of Contents....5358
SERVICE INFORMATION....5359
PRECAUTIONS....5359
Caution....5359
PREPARATION....5360
Special Service Tool....5360
Commercial Service Tool....5360
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....5361
NVH Troubleshooting Chart....5361
WHEEL HUB....5362
On-Vehicle Inspection....5362
WHEEL BEARING INSPECTION....5362
Removal and Installation....5362
COMPONENT....5362
REMOVAL....5362
Wheel Hub and Bearing Assembly....5362
Axle Housing....5363
INSPECTION AFTER REMOVAL....5363
Wheel Hub and Bearing Assembly....5363
Axle Housing....5363
Ball Joint Inspection....5363
INSTALLATION....5363
Wheel Hub and Bearing Assembly....5363
Axle Housing....5364
REAR DRIVE SHAFT....5366
Removal and Installation....5366
COMPONENT....5366
REMOVAL....5366
INSPECTION AFTER REMOVAL....5367
INSTALLATION....5367
Disassembly and Assembly....5368
COMPONENT....5368
DISASSEMBLY....5368
Final Drive Side....5368
Wheel Side....5369
INSPECTION AFTER DISASSEMBLY....5369
Shaft....5369
Joint Sub-Assembly (Wheel Side)....5369
Final Drive Side....5369
Ball Cage....5369
Steel Ball....5369
Inner Race....5369
ASSEMBLY....5370
Final Drive Side....5370
Wheel Side....5371
SERVICE DATA AND SPECIFICATIONS (SDS)....5373
Wheel Bearing....5373
Drive Shaft....5373
VK45DE model....5373
VQ35HR model....5373
rf....5374
Table of Contents....5374
SERVICE INFORMATION....5375
PRECAUTIONS....5375
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5375
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5375
Precaution....5375
PREPARATION....5376
Special Service Tool....5376
Commercial Service Tool....5376
SQUEAK AND RATTLE TROUBLE DIAGNOSIS....5377
Work Flow....5377
CUSTOMER INTERVIEW....5377
DUPLICATE THE NOISE AND TEST DRIVE....5377
CHECK RELATED SERVICE BULLETINS....5378
LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE....5378
REPAIR THE CAUSE....5378
CONFIRM THE REPAIR....5379
Inspection Procedure....5379
INSTRUMENT PANEL....5379
CENTER CONSOLE....5379
DOORS....5379
TRUNK....5379
SUNROOF/HEADLINING....5380
SEATS....5380
UNDERHOOD....5380
Diagnostic Worksheet....5381
SUNROOF....5383
Component Parts and Harness Connector Location....5383
System Description....5383
TILT UP / SLIDE CLOSE OPERATION....5383
TILT DOWN / SLIDE OPEN OPERATION....5384
AUTO OPERATION....5384
RETAINED POWER OPERATION....5384
ANTI-PINCH FUNCTION....5384
INITIALIZATION PROCEDURE....5384
Wiring Diagram - SROOF -....5385
Terminal and Reference Value for BCM....5386
Terminal and Reference Value for Sunroof Motor Assembly....5387
CONSULT-III Function (BCM)....5387
ACTIVE TEST....5387
WORK SUPPORT....5387
DATA MONITOR....5388
Work Flow....5388
Diagnosis Symptom Chart....5388
Check BCM Power Supply and Ground Circuit....5388
Check Sunroof Motor Assembly Power Supply and Ground Circuit....5389
Check Sunroof Switch....5390
Check Door Switch....5392
Fitting Adjustment....5394
RID WEATHERSTRIP OVERLAP ADJUSTMENT AND SURFACE MISMATCH ADJUSTMENT....5394
Removal and Installation....5394
SUNROOF UNIT....5395
Removal....5395
Installation....5396
Disassembly and Assembly....5397
DISASSEMBLY....5398
ASSEMBLY....5398
rfd....5399
Table of Contents....5399
SERVICE INFORMATION....5400
PRECAUTIONS....5400
Service Notice or Precaution....5400
PREPARATION....5401
Special Service Tool....5401
Commercial Service Tool....5403
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....5405
NVH Troubleshooting Chart....5405
DESCRIPTION....5406
Cross-Sectional View....5406
DIFFERENTIAL GEAR OIL....5407
Changing Differential Gear Oil....5407
DRAINING....5407
FILLING....5407
Checking Differential Gear Oil....5407
OIL LEAKAGE AND OIL LEVEL....5407
FRONT OIL SEAL....5408
Removal and Installation....5408
IDENTIFICATION STAMP OF REPLACEMENT FREQUENCY OF FRONT OIL SEAL....5408
REMOVAL....5408
INSTALLATION....5410
SIDE OIL SEAL....5412
Removal and Installation....5412
REMOVAL....5412
INSTALLATION....5412
REAR FINAL DRIVE ASSEMBLY....5414
Removal and Installation....5414
COMPONENTS....5414
REMOVAL....5414
INSTALLATION....5415
Disassembly and Assembly....5415
COMPONENTS....5415
ASSEMBLY INSPECTION AND ADJUSTMENT....5416
Total Preload Torque....5416
Drive Gear Runout....5417
Tooth Contact....5417
Backlash....5419
Companion Flange Runout....5420
DISASSEMBLY....5420
Differential Assembly....5420
Drive Pinion Assembly....5423
INSPECTION AFTER DISASSEMBLY....5424
ADJUSTMENT AND SELECTION OF ADJUSTING WASHERS....5424
Differential Side Gear Clearance....5425
Side Bearing Preload....5425
Pinion Gear Height....5426
ASSEMBLY....5429
Drive Pinion Assembly....5429
Differential Assembly....5431
SERVICE DATA AND SPECIFICATIONS (SDS)....5436
General Specification....5436
Inspection and Adjustment....5436
DRIVE GEAR RUNOUT....5436
DIFFERENTIAL SIDE GEAR CLEARANCE....5436
PRELOAD TORQUE....5436
BACKLASH....5436
COMPANION FLANGE RUNOUT....5436
SELECTIVE PARTS....5436
Side Gear Thrust Washer....5436
Pinion Height Adjusting Washer....5437
Side Bearing Adjusting Washer....5437
rsu....5438
Table of Contents....5438
SERVICE INFORMATION....5439
PRECAUTIONS....5439
Precaution....5439
PREPARATION....5440
Special Service Tool....5440
Commercial Service Tool....5440
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....5441
NVH Troubleshooting Chart....5441
REAR SUSPENSION ASSEMBLY....5442
On-Vehicle Inspection....5442
INSPECTION SUSPENSION ARM BALL JOINT AXIAL END PLAY ....5442
SHOCK ABSORBER INSPECTION....5442
Wheel Alignment Inspection....5442
DESCRIPTION....5442
PRELIMINARY INSPECTION....5442
GENERAL INFORMATION AND RECOMMENDATIONS....5442
THE ALIGNMENT PROCESS....5442
CAMBER INSPECTION....5443
TOE-IN....5443
Component....5444
Removal and Installation....5445
REMOVAL....5445
INSTALLATION....5445
SHOCK ABSORBER....5446
Removal and Installation....5446
REMOVAL....5446
INSPECTION AFTER REMOVAL....5446
INSTALLATION....5446
Disassembly and Assembly....5446
DISASSEMBLY....5446
INSPECTION AFTER DISASSEMBLY....5446
Bound Bumper and Bushing....5446
Shock Absorber....5447
ASSEMBLY....5447
Disposal....5447
SUSPENSION ARM....5448
Removal and Installation....5448
REMOVAL....5448
INSPECTION AFTER REMOVAL....5448
Visual Inspection....5448
Ball Joint Inspection....5448
Swing Torque Inspection....5448
Rotating Torque Inspection....5448
Axial End Play Inspection....5448
INSTALLATION....5449
RADIUS ROD....5450
Removal and Installation....5450
REMOVAL....5450
INSPECTION AFTER REMOVAL....5450
INSTALLATION....5450
FRONT LOWER LINK....5451
Removal and Installation....5451
REMOVAL....5451
INSPECTION AFTER REMOVAL....5451
INSTALLATION....5451
REAR LOWER LINK & COIL SPRING....5452
Removal and Installation....5452
REMOVAL....5452
INSPECTION AFTER REMOVAL....5452
INSTALLATION....5452
STABILIZER BAR....5453
Removal and Installation....5453
REMOVAL....5453
INSPECTION AFTER REMOVAL....5453
INSTALLATION....5453
SERVICE DATA AND SPECIFICATIONS (SDS)....5454
Wheel Alignment (Unladen*)....5454
Ball Joint....5454
Wheelarch Height (Unladen*)....5454
U.S.A. model ....5454
Canada model ....5454
sb....5456
Table of Contents....5456
SERVICE INFORMATION....5457
DTC INDEX....5457
U1000....5457
B2451 - B2455....5457
PRECAUTIONS....5458
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5458
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5458
Precaution for Seat Belt Service....5458
AFTER A COLLISION....5458
PRE-CRASH SEAT BELT....5460
Component Parts and Harness Connector Location....5460
System Description....5460
FUNCTION DESCRIPTION....5460
Operation condition....5460
Operation prohibition condition....5460
FAIL-SAFE MODE....5461
Seat Belt Warning Lamp Illumination Pattern ....5461
CAN Communication System Description....5461
CAN Communication Unit....5461
Schematic....5462
Wiring Diagram - PSB -....5463
Terminal and Reference Value for Pre-Crash Seat Belt Control Unit....5468
Work Flow....5469
CONSULT-III Function (PRECRASH SEATBELT)....5469
SELF-DIAGNOSTIC RESULTS ITEM CHART....5470
DATA MONITOR ITEM CHART....5470
Preliminary Check....5470
PRE-CRASH SEAT BELT OPERATION INSPECTION....5470
Diagnosis Symptom Chart....5470
Check CAN Communication Circuit [U1000]....5471
Check Ignition Power Supply Circuit....5471
Check Motor Power Supply and Ground Circuit [B2454]....5472
Check Seat Belt Buckle Switch (Driver Side) Circuit....5473
Check Seat Belt Buckle Switch (Passenger Side) Circuit....5474
Check Brake Pedal Stroke Sensor Circuit [B2453]....5476
Check Pre-Crash Seat Belt Motor LH Circuit [B2452]....5478
Check Pre-Crash Seat Belt Motor RH Circuit [B2451]....5479
Check Brake Pedal Stroke Sensor Shield Wire Circuit....5480
Removal and Installation of Pre-Crash Seat Belt Control Unit....5480
REMOVAL....5480
INSTALLATION....5481
SEAT BELTS....5482
System Description....5482
SEAT BELT WARNING CHIME....5482
SEAT BELT WARNING LAMP....5482
Removal and Installation of Front Seat Belt....5482
REMOVAL OF SEAT BELT RETRACTOR ....5482
INSTALLATION OF SEAT BELT RETRACTOR....5483
REMOVAL OF SEAT BELT BUCKLE....5483
INSTALLATION OF SEAT BELT BUCKLE....5483
Removal and Installation of Rear Seat Belt....5484
REMOVAL OF SEAT BELT RETRACTOR....5484
INSTALLATION OF SEAT BELT RETRACTOR....5484
REMOVAL OF SEAT BELT BUCKLE....5484
INSTALLATION OF SEAT BELT BUCKLE....5484
Seat Belt Inspection....5485
AFTER A COLLISION....5485
PRELIMINARY CHECKS....5485
SEAT BELT RETRACTOR ON-VEHICLE CHECK....5486
Emergency Locking Retractors (ELR) and Automatic Locking Retractors (ALR)....5486
ELR Function Stationary Check....5486
ALR Function Stationary Check....5486
ELR Function Moving Check....5486
SEAT BELT RETRACTOR OFF-VEHICLE CHECK (FRONT SEAT BELT)....5486
SEAT BELT RETRACTOR OFF-VEHICLE CHECK (REAR SEAT BELT)....5487
LATCH (LOWER ANCHORS AND TETHER FOR CHILDREN) SYSTEM....5488
Removal and Installation....5488
REMOVAL....5488
INSTALLATION....5488
TOP TETHER STRAP CHILD RESTRAINT....5489
Removal and Installation....5489
REMOVAL....5489
INSTALLATION....5489
sc....5490
Table of Contents....5490
SERVICE INFORMATION....5491
PRECAUTIONS....5491
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5491
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5491
Precaution for Power Generation Voltage Variable Control System....5491
PREPARATION....5492
Special Service Tool....5492
Commercial Service Tool....5492
BATTERY....5493
How to Handle Battery....5493
METHODS OF PREVENTING OVER-DISCHARGE....5493
CHECKING ELECTROLYTE LEVEL....5493
Sulphation....5494
SPECIFIC GRAVITY CHECK....5494
Hydrometer Temperature Correction....5494
CHARGING THE BATTERY....5495
Charging Rates....5495
Trouble Diagnosis with Battery Service Center....5495
Removal and Installation....5495
REMOVAL....5495
INSTALLATION....5496
STARTING SYSTEM....5497
System Description....5497
Wiring Diagram - START -....5498
VQ35HR ENGINE MODELS....5498
VK45DE ENGINE MODELS....5499
Trouble Diagnosis with Starting/Charging System Tester (Starting)....5499
DIAGNOSTIC PROCEDURE 1....5500
Check “B” Terminal Circuit....5500
DIAGNOSTIC PROCEDURE 2....5501
Check “S” Connector Circuit....5501
MINIMUM SPECIFICATION OF CRANKING VOLTAGE REFERENCING COOLANT TEMPERATURE....5502
Removal and Installation....5502
VQ35HR ENGINE MODELS (2WD)....5502
Removal....5503
Installation....5503
VQ35HR ENGINE MODELS (AWD)....5503
Removal....5504
Installation....5505
VK45DE ENGINE MODELS (2WD)....5505
Removal....5505
Installation....5505
VK45DE ENGINE MODELS (AWD)....5506
Removal....5506
Installation....5506
Disassembly and Assembly....5506
VQ35HR ENGINE MODELS....5506
VK45DE ENGINE MODELS(2WD)....5507
VK45DE ENGINE MODELS(AWD)....5508
Inspection After Disassembly....5509
PINION/CLUTCH CHECK ....5509
CHARGING SYSTEM....5510
System Description....5510
DESCRIPTION....5510
MALFUNCTION INDICATOR....5510
POWER GENERATION VOLTAGE VARIABLE CONTROL SYSTEM....5510
Operation Description....5510
Main Component Part....5511
Wiring Diagram - CHARGE -....5512
VQ35HR ENGINE MODELS....5512
VK45DE ENGINE MODELS....5513
Trouble Diagnosis with Starting/Charging System Tester (Charging)....5513
PRELIMINARY INSPECTION....5514
DIAGNOSTIC PROCEDURE 1....5515
Check “L” Terminal Circuit (Open)....5515
DIAGNOSTIC PROCEDURE 2....5515
Check “L” Terminal Circuit (Short)....5516
DIAGNOSTIC PROCEDURE 3....5516
Check “S” Terminal Circuit....5516
DIAGNOSTIC PROCEDURE 4....5516
Check “B” Terminal Circuit....5516
Power Generation Voltage Variable Control System Operation Inspection....5517
Removal and Installation....5518
VQ35HR ENGINE MODELS....5518
Removal (2WD)....5519
Removal (AWD)....5519
Alternator Pulley Inspection....5520
Installation ....5520
VK45DE ENGINE MODELS....5520
Removal....5521
Alternator Pulley Inspection....5521
Installation ....5522
Disassembly and Assembly....5522
VQ35HR ENGINE MODELS....5522
VK45DE ENGINE MODELS....5522
SERVICE DATA AND SPECIFICATIONS (SDS)....5524
Battery....5524
Starter....5524
Alternator....5524
se....5526
Table of Contents....5526
SERVICE INFORMATION....5528
DTC INDEX....5528
U1000....5528
B2112-B2128....5528
PRECAUTIONS....5529
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5529
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5529
Service Notice....5529
Precaution for Work....5529
PREPARATION....5531
Special Service Tool....5531
Commercial Service Tool....5531
SQUEAK AND RATTLE TROUBLE DIAGNOSIS....5532
Work Flow....5532
CUSTOMER INTERVIEW....5532
DUPLICATE THE NOISE AND TEST DRIVE....5532
CHECK RELATED SERVICE BULLETINS....5533
LOCATE THE NOISE AND IDENTIFY THE ROOT CAUSE....5533
REPAIR THE CAUSE....5533
CONFIRM THE REPAIR....5534
Inspection Procedure....5534
INSTRUMENT PANEL....5534
CENTER CONSOLE....5534
DOORS....5534
TRUNK....5534
SUNROOF/HEADLINING....5535
SEATS....5535
UNDERHOOD....5535
Diagnostic Worksheet....5536
AUTOMATIC DRIVE POSITIONER....5538
Component Parts and Harness Connector Location....5538
System Description....5538
MANUAL OPERATION....5539
MEMORY OPERATION....5539
Operation procedure....5539
Operation Condition....5539
Storing Memory Procedure....5539
EXITING OPERATION....5540
Operation Condition....5540
ENTRY OPERATION....5540
Operation Condition....5540
INTELLIGENT KEY INTERLOCK OPERATION....5541
Operation procedure....5541
Operation Condition....5541
Linking Intelligent Key to the Stored Memory Procedure....5541
FAIL-SAFE MODE....5541
Canceling Fail-safe Mode....5541
INITIALIZATION PROCEDURE....5541
SETTING CHANGE FUNCTION....5542
CAN Communication System Description....5542
CAN Communication Unit....5542
Schematic....5543
Wiring Diagram - AUT/DP -....5545
Terminal and Reference Value for BCM....5556
Terminal and Reference Value for Intelligent Key Unit....5556
Terminal and Reference Value for Driver Seat Control Unit....5557
Terminal and Reference Value for Automatic Drive Positioner Control Unit....5559
CONSULT-III Function (AUTO DRIVE POS.)....5561
SELF-DIAGNOSIS RESULTS....5561
DATA MONITOR....5562
ACTIVE TEST....5563
WORK SUPPORT....5563
Work Flow....5563
Symptom Chart....5563
CAN Communication Inspection Using CONSULT-III (Self-Diagnosis)....5564
Check BCM Power Supply and Ground Circuit....5565
Check Driver Seat Control Unit Power Supply and Ground Circuit....5565
Check Automatic Drive Positioner Control Unit Power Supply and Ground Circuit....5566
Check Sliding Motor Circuit....5567
Check Reclining Motor Circuit....5568
Check Front Lifting Motor Circuit....5569
Check Rear Lifting Motor Circuit....5570
Check Telescopic Motor Circuit....5571
Check Tilt Motor Circuit....5573
Check Sliding Sensor Circuit....5574
Check Reclining Sensor Circuit....5575
Check Front Lifting Sensor Circuit....5577
Check Rear Lifting Sensor Circuit....5578
Check Telescopic Sensor Circuit....5579
Check Tilt Sensor Circuit....5580
Check Door Mirror Sensor LH Circuit....5582
Check Door Mirror Sensor RH Circuit....5583
Check Sliding Switch Circuit....5585
Check Reclining Switch Circuit....5586
Check Lifting Switch (Front) Circuit....5588
Check Lifting Switch (Rear) Circuit....5589
Check Power Seat Switch Ground Circuit....5590
Check Telescopic Switch Circuit....5591
Check Tilt Switch Circuit....5592
Check Seat Memory and Set Switch Circuit....5594
Check Seat Memory Indicator Lamp Circuit....5595
Check Door Mirror Sensor Power Supply and Ground Circuit....5597
Check A/T Shift Selector (Detent Switch) Circuit....5598
Check Front Door Switch (Driver Side) Circuit....5599
Check UART Communication Line Circuit....5600
Check Lumbar Support Circuit....5602
POWER SEAT(PASSENGER SIDE)....5604
Schematic....5604
Wiring Diagram - SEAT -....5605
POWER SEAT(REAR)....5608
Component Parts and Harness Connector Location....5608
System Description....5608
REAR POWER SEAT LH AND RH OPERATION....5608
REAR SEAT RETREAT FUNCTION....5609
Schematic....5610
Wiring Diagram - R/SEAT -....5611
Terminal and Reference Value for Rear Seat Control Unit....5614
Work Flow....5615
Trouble Diagnosis Symptom Chart....5615
Check Rear Power Seat Power Supply Circuit....5616
Check Rear Seat Control Unit Power Supply and Ground Circuit....5616
Check Rear Seat Sliding Motor Circuit....5617
Check Rear Power Seat Switch Circuit....5617
Check Automatic Return Cancel Switch Circuit....5619
Check Automatic Return Cancel Switch....5620
Check Rear Door Switch Circuit....5621
Check Rear Seat Sliding Sensor Circuit....5622
CLIMATE CONTROLLED SEAT....5624
Component Parts and Harness Connector Location....5624
System Description....5624
Schematic....5627
Wiring Diagram - C/SEAT -....5628
Terminal and Reference Value for Climate Controlled Seat Control Unit....5633
Work Flow....5634
Trouble Diagnosis Symptom Chart....5634
Preliminary Check....5635
Check Climate Controlled Seat Control Unit Power Supply Circuit....5635
Check Climate Controlled Seat Control Unit Power Supply and Ground Circuit....5636
Check Climate Controlled Seat Switch Power Supply Circuit....5638
Check Climate Controlled Seat Switch Circuit....5639
Check Climate Controlled Seat Switch Indicator Circuit....5641
Check Seat Cushion Thermal Electric Device Circuit....5642
Check Seatback Thermal Electric Device Circuit....5643
Check Seat Cushion Thermal Electric Device Sensor Circuit....5644
Check Seatback Thermal Electric Device Sensor Circuit....5646
Check Climate Controlled Seat Blower Motor Circuit....5647
Check Climate Controlled Seat Control Unit....5648
HEATED SEAT....5650
Component Parts and Harness Connector Location....5650
System Description....5650
Schematic....5652
Wiring Diagram - HSEAT -....5653
Terminal and Reference Value for Rear Seat Control Unit....5657
Work Flow....5658
Trouble Diagnosis Symptom Chart....5658
Check Rear Heated Seat Power Supply and Ground Circuit....5658
Check Rear Seat Control Unit Power Supply and Ground Circuit....5659
Check Rear Heated Seat Switch Circuit....5661
Check Rear Heated Seat Indicator Power Supply Circuit....5662
Check Rear Heated Seat Indicator Circuit....5664
Check Rear Heated Seat Circuit....5665
Check Rear Seatback Heater Circuit....5666
FRONT SEAT....5668
Driver's Seat Component....5668
Passenger's Seat Component....5670
Removal and Installation....5671
REMOVAL....5671
INSTALLATION....5671
Disassembly and Assembly....5672
SEATBACK....5672
Disassembly....5672
Assembly....5673
SEAT CUSHION....5673
Disassembly....5673
Assembly....5675
CLIMATE CONTROLLED SEAT....5675
Blower Filter Replacement....5675
REAR SEAT....5677
Bench Seat Component....5677
Power Seat (Split Type) Component....5678
Removal and Installation....5679
BENCH SEAT....5679
Removal....5679
Installation....5679
POWER SEAT....5679
Removal....5679
Installation....5680
Disassembly and Assembly....5680
BENCH SEAT....5680
Disassembly of Seat Cushion....5680
Assembly of Seat Cushion....5680
Disassembly of Seatback....5680
Assembly of Seatback....5681
Disassembly of Armrest....5681
Assembly of Armrest....5682
POWER SEAT....5682
Disassembly of Seat Cushion....5682
Assembly of Seat Cushion....5682
Disassembly of Seatback....5682
Assembly of Seatback....5682
Disassembly of Seat Frame....5682
Assembly of Seat Frame....5682
Disassembly of Armrest....5682
Assembly of Armrest....5683
srs....5684
Table of Contents....5684
SERVICE INFORMATION....5685
DTC INDEX....5685
B1001-B1015....5685
B1017-B1031....5685
B1033-B1047....5686
B1049-B1063....5686
B1065-B1079....5687
B1081-B1111....5687
B1113-B1127....5688
B1129-B1143....5688
B1145-B1210....5688
PRECAUTIONS....5690
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5690
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5690
Precaution for SRS "AIR BAG" and "SEAT BELT PRE-TENSIONER" Service....5690
Occupant Classification System Precaution....5690
PREPARATION....5691
Commercial Service Tool....5691
SUPPLEMENTAL RESTRAINT SYSTEM (SRS)....5692
SRS Configuration....5692
Front Seat Belt Pre-tensioner with Load Limiter....5693
Front Side Air Bag....5693
Side Curtain Air Bag....5693
Occupant Classification System (OCS)....5693
Passenger Air Bag Status Condition....5694
Component Parts of Occupant Classification System....5694
Passenger Seatbelt Warning System....5694
SYSTEM DESCRIPTION....5694
This system is composed of the following items...5694
TROUBLE DIAGNOSIS....5695
Trouble Diagnosis Introduction....5695
DIAGNOSIS FUNCTION....5695
HOW TO PERFORM TROUBLE DIAGNOSIS FOR QUICK AND ACCURATE REPAIR....5695
Information from Customer....5695
Preliminary Check....5695
WORK FLOW....5695
DETAILED FLOW....5696
Component Parts Location....5697
Schematic....5698
Wiring Diagram - SRS -....5699
CONSULT-lll Function....5703
DIAGNOSIS MODE FOR CONSULT-lll....5703
HOW TO CHANGE SELF-DIAGNOSIS MODE WITH CONSULT-lII....5704
From User Mode to Diagnosis Mode....5704
From Diagnosis Mode to User Mode....5704
HOW TO ERASE SELF-DIAGNOSTIC RESULTS....5704
Self-Diagnosis Function (Without CONSULT-lll)....5704
HOW TO CHANGE SELF-DIAGNOSTIC MODE WITHOUT CONSULT-lll....5704
HOW TO ERASE SELF-DIAGNOSTIC RESULTS....5704
SRS Operation Check (USER MODE)....5705
DIAGNOSTIC PROCEDURE ....5705
Checking Air Bag Operation by Using “AIR BAG” Warning Lamp-User Mode....5705
Trouble Diagnosis with CONSULT-IlI....5706
DIAGNOSTIC PROCEDURE....5706
DTC No. Index (“SELF-DIAG [CURRENT]” “SELF-DIAG [PAST]” or TROUBLE DIAG RECORD )....5706
Trouble Diagnosis without CONSULT-IlI....5710
DIAGNOSTIC PROCEDURE ....5710
Inspecting SRS Malfunctioning Parts by Using “AIR BAG” Warning Lamp - Diagnosis Mode....5711
WARNING LAMP FLASH CODE CHART....5711
Trouble Diagnosis: "AIR BAG" Warning Lamp Does Not Turn OFF....5714
DIAGNOSTIC PROCEDURE....5714
Trouble Diagnosis: "AIR BAG" Warning Lamp Does Not Turn ON....5714
DIAGNOSTIC PROCEDURE....5714
Trouble Diagnosis: Passenger Seat belt Warning System....5715
DRIVER AIR BAG MODULE....5716
Removal and Installation....5716
REMOVAL....5716
INSTALLATION....5717
SPIRAL CABLE....5718
Removal and Installation....5718
REMOVAL....5718
INSTALLATION....5719
FRONT PASSENGER AIR BAG MODULE....5720
Removal and Installation....5720
REMOVAL....5720
INSTALLATION....5721
SIDE CURTAIN AIR BAG MODULE....5722
Removal and Installation....5722
REMOVAL....5722
INSTALLATION....5723
CRASH ZONE SENSOR....5724
Removal and Installation....5724
REMOVAL....5724
INSTALLATION....5724
SIDE AIR BAG (SATELLITE) SENSOR....5725
Removal and Installation....5725
REMOVAL....5725
INSTALLATION....5725
FRONT SEAT BELT PRE-TENSIONER....5726
Removal and Installation....5726
DIAGNOSIS SENSOR UNIT....5727
Removal and Installation....5727
REMOVAL....5727
INSTALLATION....5727
OCCUPANT CLASSIFICATION SYSTEM CONTROL UNIT....5729
Removal and Installation....5729
COLLISION DIAGNOSIS....5730
For Frontal Collision....5730
SRS INSPECTION (FOR FRONTAL COLLISION)....5730
For Side Collision....5731
WHEN THE SIDE AIR BAG IS ACTIVATED IN THE SIDE COLLISION:....5731
WHEN SRS IS NOT ACTIVATED IN THE SIDE COLLISION:....5731
SRS INSPECTION (FOR SIDE COLLISION)....5731
stc....5733
Table of Contents....5733
EPS....5734
SERVICE INFORMATION....5734
PRECAUTIONS....5734
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5734
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5734
SYSTEM DESCRIPTION....5735
Component....5735
Component (Models with Rear Active Steer)....5735
Electronically Controlled Power Steering System Function....5735
Fail-Safe Function....5736
FAIL-SAFE INPUT/CANCEL CONDITIONS....5736
TROUBLE DIAGNOSIS....5737
How to Perform Trouble Diagnosis....5737
BASIC CONCEPT....5737
Component Parts Location....5737
Wiring Diagram - EPS -....5738
Control Unit Input/Output Signal Standard....5739
STANDARD BY CIRCUIT TESTER AND OSCILLOSCOPE....5739
For Fast and Accurate Trouble Diagnosis....5740
Basic Inspection....5741
POWER SUPPLY CIRCUIT TERMINAL LOOSENESS AND BATTERY....5741
Inspection: Power Steering Control Unit Power Supply Circuit and Ground....5741
Symptom: the Steering Force Does Not Change Smoothly According to the Vehicle Speed....5741
RAS....5745
SERVICE INFORMATION....5745
DTC INDEX....5745
C1900-C1913....5745
C1914-C1929....5745
U1000-U1010....5745
PRECAUTIONS....5746
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5746
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5746
REAR ACTIVE STEER....5747
Removal and Installation....5747
COMPONENTS....5747
REMOVAL....5747
INSTALLATION....5747
SYSTEM DESCRIPTION....5748
Component....5748
RAS (Rear Active Steer) Function....5748
Fail-Safe Function....5749
TROUBLE DIAGNOSIS....5750
How to Perform Trouble Diagnosis....5750
BASIC CONCEPT....5750
Component Parts Location....5751
Schematic....5752
Wiring Diagram - RAS -....5753
Control Unit Input/Output Signal Standard....5758
CIRCUIT TESTER REFERENCE VALUE....5758
STANDARD BY CONSULT-III....5759
CONSULT-III Function (RAS/HICAS)....5760
FUNCTION....5760
SELF-DIAG RESULT MODE....5760
Display Item List....5760
DATA MONITOR MODE....5762
Display Item List....5762
ACTIVE TEST MODE....5762
Test Item....5762
Diagnosis Procedure with Self-Diagnosis Function (Without CONSULT-III)....5762
DESCRIPTION....5762
SELF-DIAGNOSIS PROCEDURE....5762
SELF-DIAGNOSIS DISPLAY....5763
SELF-DIAGNOSIS DISPLAY ITEMS....5763
HOW TO ERASE SELF-DIAGNOSIS....5763
CAN Communication....5763
For Fast and Accurate Trouble Diagnosis....5763
Basic Inspection....5764
BASIC INSPECTION 1: POWER SUPPLY CIRCUIT TERMINAL LOOSENESS AND BATTERY....5764
BASIC INSPECTION 2: RAS WARNING LAMP INSPECTION....5764
BASIC INSPECTION 3: RAS CONTROL UNIT POWER SUPPLY CIRCUIT AND GROUND CIRCUIT INSPECTION....5764
Trouble Diagnosis Chart....5765
SELF-DIAGNOSIS....5765
DIAGNOSIS CHART BY SYMPTOM....5765
Inspection 1 RAS Control Unit Malfunction....5766
Inspection 2 Motor Power Supply System....5766
Inspection 3 RAS Motor Output Malfunction....5768
Inspection 4 Vehicle Speed Signal....5769
Inspection 5 Steering Angle Signal Malfunction....5769
Inspection 6 Rear Main Signal and Rear Sub Signal Malfunction....5770
Inspection 7 VDC Malfunction....5773
Inspection 8 Engine Speed Signal Malfunction....5773
Inspection 9 CAN Communication System Malfunction....5774
Inspection 10 Stop Lamp Switch Harness....5774
Inspection 11 RAS Warning Lamp Signal....5774
INSPECTION PROCEDURE....5774
Diagnosis Chart by Symptom 1....5775
Diagnosis Chart by Symptom 2....5775
Check RAS Static/Dynamic Characteristics....5777
Component Inspection....5778
RAS MOTOR RELAY....5778
RAS MOTOR....5778
REAR WHEEL STEERING ANGLE SENSOR....5778
wt....5779
Table of Contents....5779
SERVICE INFORMATION....5781
DTC INDEX....5781
C1704-C1707....5781
C1708-C1711....5781
C1716-C1719....5781
C1720-C1723....5781
C1724-C1727....5781
C1728....5781
C1729....5782
C1750-C1753....5782
C1754....5782
U1000....5782
U1010....5782
PRECAUTIONS....5783
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5783
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5783
Precaution....5783
PREPARATION....5784
Special Service Tool....5784
Commercial Service Tool....5784
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING....5785
NVH Troubleshooting Chart....5785
ROAD WHEEL....5786
Inspection....5786
ALUMINUM WHEEL....5786
STEEL WHEEL....5786
ROAD WHEEL AND TIRE ASSEMBLY....5787
Balancing Wheels (Bonding Weight Type)....5787
REMOVAL....5787
WHEEL BALANCE ADJUSTMENT ....5787
Rotation....5788
TIRE PRESSURE MONITORING SYSTEM....5789
System Component....5789
System Description....5789
TRANSMITTER....5789
RECEIVER....5789
LOW TIRE PRESSURE WARNING CONTROL UNIT....5790
LOW TIRE PRESSURE WARNING LAMP....5790
Low Tire Pressure Warning Lamp Indication....5790
DISPLAY UNIT....5790
Can Communication....5790
TROUBLE DIAGNOSIS....5792
How to Perform Trouble Diagnosis....5792
BASIC CONCEPT....5792
Schematic....5793
Wiring Diagram - T/WARN -....5794
Low Tire Pressure Warning Control Unit Input/Output Signal Standard....5796
ID Registration Procedure....5797
ID REGISTRATION WITH ACTIVATION TOOL....5797
ID REGISTRATION WITHOUT ACTIVATION TOOL....5798
Transmitter Wake Up Operation....5798
WITH TRANSMITTER ACTIVATION TOOL....5798
CONSULT-III Function (AIR PRESSURE MONITOR)....5799
DESCRIPTION....5799
WORK SUPPORT MODE....5799
SELF-DIAG RESULT MODE....5799
Item List....5799
DATA MONITOR MODE....5800
Display Item List....5800
ACTIVE TEST MODE....5801
Test Item....5801
LOW TIRE PRESSURE WARNING CONTROL UNIT PART NUMBER....5801
Operation Procedure....5801
Diagnosis Procedure with Warning Lamp Function (Without CONSULT-III)....5801
DESCRIPTION....5801
FUNCTION....5801
LOW TIRE PRESSURE WARNING LAMP DIAGNOSTIC CHART....5801
How to Perform Trouble Diagnosis for Quick and Accurate Repair....5803
INTRODUCTION....5803
WORK FLOW....5803
Preliminary Check....5804
Trouble Diagnosis Chart....5805
SELF-DIAGNOSIS....5805
DIAGNOSIS CHART BY SYMPTOM....5806
TROUBLE DIAGNOSIS FOR SYSTEM....5807
Transmitter no Data....5807
MALFUNCTION CODE NO. 21, 22, 23, 24....5807
Receiver Data Error....5807
MALFUNCTION CODE NO. 25, 26, 27, 28....5807
Transmitter Pressure Data Error....5808
MALFUNCTION CODE NO. 35, 36, 37, 38....5808
Transmitter Function Code Error....5809
MALFUNCTION CODE NO. 41, 42, 43, 44....5809
Transmitter Battery Voltage Low....5809
MALFUNCTION CODE NO. 45, 46, 47, 48....5809
Receiver ID No Registration....5810
MALFUNCTION CODE NO. 51....5810
Vehicle Speed Signal....5810
MALFUNCTION CODE NO. 52....5810
Control Unit (EEPROM) Malfunction....5810
MALFUNCTION CODE NO. 54....5810
CAN Communication System Malfunction....5811
TROUBLE DIAGNOSIS FOR SYMPTOMS....5812
Warning Lamp Does Not Come On When Ignition Switch Is Turned ON....5812
Warning Lamp Stay On When Ignition Switch Is Turned ON....5812
Warning Lamp Blinks 1 Minute and Then Turns ON When Ignition Switch Is Turned ON....5812
Warning Lamp Blinks When Ignition Switch Is Turned ON....5813
Turn Signal Lamp Blinks When Ignition Switch Is Turned ON....5814
ID Registration Cannot Be Completed....5814
REMOVAL AND INSTALLATION....5815
Transmitter....5815
REMOVAL....5815
INSTALLATION....5815
Low Tire Pressure Warning Control Unit....5816
REMOVAL....5816
INSTALLATION....5816
Receiver....5816
REMOVAL....5816
INSTALLATION....5816
SERVICE DATA AND SPECIFICATIONS (SDS)....5817
Road Wheel....5817
Tire....5817
ww....5818
Table of Contents....5818
SERVICE INFORMATION....5819
PRECAUTION....5819
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER"....5819
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS....5819
Precaution for Procedure without Cowl Top Cover....5819
FRONT WIPER AND WASHER SYSTEM....5820
Component Parts and Harness Connector Location....5820
System Diagram....5820
System Description....5821
OUTLINE....5821
FRONT WIPER BASIC OPERATION....5821
FRONT WIPER LO OPERATION....5821
FRONT WIPER HI OPERATION....5821
FRONT WIPER AUTO OPERATION (RAIN SENSING WIPER)....5821
Rain Sensing....5821
Auto Wiping Operation ....5822
Rain Sensor Sensitivity Setting....5822
FRONT WIPER AUTO STOP OPERATION....5822
FRONT WIPER OPERATION LINKED WITH WASHER....5822
FAIL-SAFE FUNCTION....5822
CAN Communication Error....5822
Front Wiper Motor Protection....5822
Rain Sensor Malfunction....5823
COMBINATION SWITCH READING FUNCTION....5823
CAN Communication System Description....5823
CAN Communication Unit....5823
Schematic....5824
Wiring Diagram - WIPER -....5825
Terminal and Reference Value for BCM....5829
Terminal and Reference Value for IPDM E/R....5833
How to Perform Trouble Diagnosis....5833
Preliminary Check....5833
CHECK POWER SUPPLY AND GROUND CIRCUIT....5833
CONSULT-III Functions (BCM)....5834
DATA MONITOR....5835
Display Item List....5835
ACTIVE TEST....5835
Display Item List....5835
CONSULT-III Functions (IPDM E/R)....5835
DATA MONITOR....5835
All Signals, Main Signals, Selection From Menu....5835
ACTIVE TEST....5836
Front Wiper Does Not Operate....5836
Front Wiper Does Not Return to Stop Position (After Front Wiper Operate for 10 Seconds, They Stop for 20 Seconds, and After Repeating the Operation Five Times, They Become Inoperative)....5838
Front Wiper Does Not Return to Stop Position When Front Wiper Motor Operates at Low Speed (After Front Wiper Operate for 10 Seconds, They Stop for 20 Seconds, and After Repeating the Operation Five Times, They Become Inoperative)....5839
Front Wiper Does Not Return to Stop Position When Front Wiper Motor Operates at HIGH Speed (After Front Wiper Operate for 10 Seconds, They Stop for 20 Seconds, and After Repeating the Operation Five Times, They Become Inoperative)....5840
Only Front Wiper Low Does Not Operate....5842
Only Front Wiper HI Does Not Operate....5843
Only Front Wiper Auto Does Not Operate....5845
Front Wiper Intermittent Operation Switch Position Cannot Be Adjusted....5847
Wiper Does Not Wipe When Front Washer Operates....5847
Front Wiper Does Not Stop....5847
Removal and Installation of Front Wiper Arms, Adjustment of Wiper Arms Stop Location....5847
REMOVAL....5847
INSTALLATION....5847
ADJUSTMENT....5848
Removal and Installation of Front Wiper Drive Assembly....5848
REMOVAL....5848
INSTALLATION....5848
Disassembly and Assembly of Front Wiper Drive Assembly....5849
DISASSEMBLY....5849
ASSEMBLY....5849
Washer Nozzle Adjustment....5850
Washer Tube Layout....5851
Removal and Installation of Front Washer Nozzle....5851
REMOVAL....5851
INSTALLATION....5851
Inspection for Washer Nozzle....5851
CHECK VALVE INSPECTION....5851
Inspection of Front Wiper and Washer Switch Circuit....5852
Removal and Installation of Front Wiper and Washer Switch....5852
REMOVAL....5852
INSTALLATION....5852
Removal and Installation of Washer Tank....5852
REMOVAL....5852
INSTALLATION....5852
Removal and Installation of Washer Pump....5853
REMOVAL....5853
INSTALLATION....5853
Removal and Installation of Rain Sensor....5853
EXPLODED VIEW....5853
REMOVAL....5853
INSTALLATION....5854
CIGARETTE LIGHTER....5855
Wiring Diagram - CIGAR -....5855
Removal and Installation....5855
REMOVAL....5855
INSTALLATION....5856
POWER SOCKET....5857
Wiring Diagram - P/SCKT -....5857
Removal and Installation of Center Console Box Power Socket....5857
REMOVAL....5857
INSTALLATION....5858
Removal and Installation of Center Console Box Rear Side Power Socket....5858
REMOVAL....5858
INSTALLATION....5858
HORN....5859
Wiring Diagram - HORN -....5859
Removal and Installation....5859
REMOVAL....5859
INSTALLATION....5860
Infiniti M35, M45 (Y50-Sereis) Service & Repair Manual 2006-2010
