John Deere StarFire 3000 Technical Manual (TM117919)

tm117919 - John Deere StarFire 3000 Technical Manual.pdf

Complete technical repair manual for John Deere StarFire 3000, with all the shop information to maintain, diagnostic, repair, refurbish/rebuild like professional mechanics.

PRODUCT DETAILS:
Total Pages: 368 pages
File Format: PDF (Internal Links, Bookmarked, Table of Contents, Searchable, Printable, high quality)
Language: English

tm117919 - StarFire™ 3000 Technical Manual

Table of Contents

Foreword

Section 210: General Information

Group 05A: Safety

Recognize Safety Information

Understand Signal Words

Follow Safety Instructions

Practice Safe Maintenance

Use Steps and Handholds Correctly

Handle Electronic Components and Brackets Safely

Waste Electrical and Electronic Equipment

Use Electronic Display Properly

Group 05B: General References

Information Available in Sections, Groups and Subgroups

Group 05C: References for Technical Information

StarFire™ 3000 Receiver

Group 20: Theory of Operation

StarFire™ 3000 Theory of Operation

Mobile RTK Theory of Operation

Group 100A: Factory Support Information

Well Prepared DTAC Case

Section 211: Diagnostic Trouble Codes

Group ITC: Integrated Terrain Compensation Diagnostic Trouble Codes (iTC)

iTC 000158.03 - Switched Voltage is too High

iTC 000158.04 - Switched Voltage is too Low

iTC 000168.03 - Unswtiched Voltage is too High

iTC 000168.04 - Unswitched Voltage is too Low

iTC 000168.18 - RTK Base Station Voltage Low

iTC 000232.02 - Corrected GPS Position not Available

iTC 000232.14 - RTK Extend Lost

iTC 000444.04 - Invalid Application Configuration

iTC 000629.12 - Reset Occurred

iTC 000639.12 - Missing Messages from the CAN Bus

iTC 000639.14 - CAN Bus Off

iTC 000841.07 - GPS Receiver Internal Failure

iTC 000841.31 - Signal Interference from Satellite

iTC 000956.16 - Roll Sensor is Out of Normal Range

iTC 002146.13 - TCM Not Calibrated

iTC 002146.14 - iTC Temperature Sensor Out of Range

iTC 002850.05 - Reflected Antenna Power

iTC 002854.09 - Corrections Age Exceeded

iTC 002854.31 - RTK Rover Radio Link Lost

iTC 003141.14 - Receiver to Base Station License has Expired

iTC 003141.31 - GPS Corrections License Expired

iTC 003144.13 - Receiver NOT Receiving on Alternate Frequency

iTC 516198.16 - Base Station Quality Indicator

iTC 516218.00 - Connection Error

iTC 516218.02 - Invalid Username / Password

iTC 516218.13 - Invalid Mobile RTK Configuration

iTC 516218.14 - Authorization Request Error

iTC 516218.31 - Mobile RTK License

iTC 516223.14 - Invalid Mount Point

iTC 516224.14 - Incorrect Signal Type

iTC 516420.14 - JDLink™ Modem Cannot Connect to Network

iTC 516421.14 - Mobile RTK Cellular Signal Low

iTC 516422.14 - JDLink™ Modem Failed to Connect

iTC 520527.14 - Mobile RTK Corrections are NOT Recognized

iTC 520527.31 - Mobile RTK Network

iTC 520650.14 - Modem Status Idle

iTC 520658.07 - JDLink™ Modem NOT Receiving GPS Position

iTC 522339.31 - GPS Corrections License Expired

iTC 522394.13 - TCM Not Calibrated

iTC 522552.11 - StarFire™ Network Fault

iTC 523187.02 - Invalid License Activation Received from StarFire™ Satellite

iTC 523274.02 - GPS Position Not Available

iTC 523309.07 - Yaw Sensor Out of Range

iTC 523309.16 - Yaw Sensor Not Responding

iTC 523310.02 - Memory Fault

iTC 523319.18 - Low Switched Voltage

iTC 523348.07 - TCM Communication Failure

iTC 523348.12 - TCM Sensor Failure

iTC 523348.16 - TCM Temperature Out of Range

iTC 523441.31 - No StarFire™ Height Dimension

iTC 523442.31 - No StarFire™ Fore/Aft Set

iTC 523572.31 - Power Shutdown Fault

iTC 523773.03 - Machine CAN Hi Line Voltage High

iTC 523773.04 - Machine CAN Hi Line Voltage Low

iTC 523774.03 - Machine CAN Lo Line Voltage High

iTC 523774.04 - Machine CAN Lo Line Voltage Low

iTC 523792.18 - Low Unswitched Voltage

iTC 524209.01 - Single Site

iTC 524209.14 - Outside Mobile RTK Network Boundary

iTC 524209.16 - Invalid Location

iTC 524209.31 - RTK Data Unavailable

iTC 524210.16 - RTK Base Station Not Using Visible Satellites

iTC 524257.14 - RTK Base Station Position Survey in Progress

iTC 524257.16 - RTK Base Station Relocation

iTC 524257.19 - RTK Base Station Location Interference

Group IR1: Implement Receiver 1 Diagnostic Trouble Codes (IR1)

IR1 000158.03 - Switched Voltage is too High

IR1 000158.04 - Switched Voltage is too Low

IR1 000168.03 - Unswitched Voltage is too High

IR1 000168.04 - Unswitched Voltage is too Low

IR1 000168.18 - RTK Base Station Voltage Low

IR1 000232.02 - Corrected GPS Position not Available

IR1 000232.14 - RTK Extend Lost

IR1 000444.04 - Invalid Application Configuration

IR1 000629.12 - Reset Occurred

IR1 000639.12 - Missing Messages from the CAN Bus

IR1 000639.14 - CAN Bus Off

IR1 000841.07 - GPS Receiver Internal Failure

IR1 000841.31 - Signal Interference from Satellite

IR1 000956.16 - Roll Sensor is Out of Normal Range

IR1 002146.13 - TCM Not Calibrated

IR1 002146.14 - iTC Temperature Sensor Out of Range

IR1 002850.05 - Reflected Antenna Power

IR1 002854.09 - Corrections Age Exceeded

IR1 002854.31 - RTK Rover Radio Link Lost

IR1 003141.14 - Receiver to Base Station License has Expired

IR1 003141.31 - GPS Corrections License Expired

IR1 003144.13 - Receiver NOT Receiving on Alternate Frequency

IR1 516198.16 - Base Station Quality Indicator

IR1 516218.00 - Connection Error

IR1 516218.02 - Invalid Username / Password

IR1 516218.13 - Mobile RTK Configuration is Invalid

IR1 516218.14 - Authorization Request Error

IR1 516218.31 - Mobile RTK Lisense

IR1 516223.14 - Invalid Mount Point

IR1 516224.14 - Incorrect Signal Type

IR1 516420.14 - JDLink™ Modem Cannot Connect to Network

IR1 516421.14 - Mobile RTK Cellular Signal is Low

IR1 516422.14 - JDlink™ Modem Failed to Connect

IR1 520527.31 - Mobile RTK Network

IR1 520650.14 - Modem Status Idle

IR1 520658.07 - JDLink™ Modem NOT Receiving GPS Postion

IR1 522339.31 - GPS Corrections License Expired

IR1 522394.13 - TCM Not Calibrated

IR1 522552.11 - StarFire™ Network Fault

IR1 523187.02 - Invalid License Activation Received from StarFire™ Satellite

IR1 523274.02 - GPS Position Not Available

IR1 523309.07 - Yaw Sensor Out of Range

IR1 523309.16 - Yaw Sensor Not Responding

IR1 523310.02 - Memory Fault

IR1 523319.18 - Low Switched Voltage

IR1 523348.07 - TCM Communication Failure

IR1 523348.12 - TCM Sensor Failure

IR1 523348.16 - TCM Temperature Out of Range

IR1 523441.31 - No StarFire™ Height Dimension

IR1 523442.31 - No StarFire™ Fore/Aft Set

IR1 523572.31 - Power Shutdown Fault

IR1 523773.03 - Vehicle CAN Hi Line Voltage High

IR1 523773.04 - Vehicle CAN Hi Line voltage Low

IR1 523774.03 - Vehicle CAN Lo Line Voltage High

IR1 523774.04 - Vehicle CAN Lo Line Voltage Low

IR1 523792.18 - Low Unswitched Voltage

IR1 524209.01 - Single Site

IR1 524209.14 - Outside Mobile RTK Network Boundary

IR1 524209.16 - Invalid Location

IR1 524209.31 - RTK Data Unavailable

IR1 524257.14 - RTK Base Station Position Survey in Progress

IR1 524257.16 - RTK Base Station Relocation

IR1 524257.19 - RTK Base Station Location Interference

Section 212: Observable Symptom and System Diagnostics

Group 45: Electronic Control Units

AutoTrac™ No TCM Correction Failure

StarFire™ 3000 LED Chart

Base Station Upgrade Had Lower Data Readings

Extreme Coverage Map and Boundary Shifts

GSD4 AutoTrac SF1 Disabled When Using SF1 Only Receiver

Low Signal or Loss of Signal

Machine Receiver Shows as Implement Receiver

Mobile RTK Accuracy is Bad

Mobile RTK Will NOT Connect

No / Bad Cellular Network Connection

No Power/No Communication with StarFire™ 3000

Receiver Will Not Update to Latest Software

SF2 Performance Issues - Intermittent AutoTrac™

StarFire™ Receiver Loses SF1, SF2, or All Global Position System (GPS) Signals.

StarFire™ Stuck in Bootloader

TCM Calibration Failure Alert Screens

Will Not Acquire Satellites or Drops Signal Intermittently

Section 245: Electronic Control Units

Group 05: General Information

USB Drive

Servicing Electronic Control Units

Welding Near Electronic Control Units

Keep Electronic Control Unit Connectors Clean

Access GreenStar™ 3 Diagnostic Addresses and Diagnostic Trouble Codes

Accessing Generation 4 Display Control Unit Addresses

Generation 4 Display View and Clear Codes

Control Unit Beep Mode Test

Collecting Error Logs and Debug Data

Electrical Tools - Summary of References

Group 10A: Operational and Preliminary Checks

Service ADVISOR™ Overview

Service ADVISOR™ Connection Utilizing EDL

Service ADVISOR™ Starting a New Job

Service ADVISOR™ GVI Installation Procedure

Service ADVISOR™ GVI Run Procedure

Service ADVISOR™ Diagnostic Trouble Codes

Service ADVISOR™ Diagnostics Readings Tab

Service ADVISOR™ Diagnostics Observed Symptoms Tab

Service ADVISOR™ Diagnostics CAN Trace

Service ADVISOR™ Job Activity Filters

Receiver Height Optimization

TCM Optimization on 2630 Display

TCM Optimization on Generation 4 Display

Group 10B: Interactive Tests and Calibrations

Service ADVISOR™ GenInfoTest Procedure

Connecting Receiver to Non-Deere Control Unit

Improving Signal When Shading Occurs

Group 10C: Programming Electronic Control Units

Determining 2630 Display Software Version

Determining Generation 4 Display Software Version

Remote Software Programming with GreenStar™ 3 2630 Display

Remote Software Programming with Generation 4 Display

USB Software Updates

USB Software Update Procedure

Group 30: Schematic

Schematic

RTK Radio to StarFire™ 3000 Schematic

Mobile RTK Harness for Machines with Integrated GreenStar™

Mobile RTK Harness for Machines with GreenStar™

Group 50: Diagnostic Tests and Adjustments

No Communication with StarFire™ 3000 Diagnostics

Low Signal or Loss of Signal with StarFire™ 3000

Group IR1: Implement Receiver 1 Addresses (IR1)

Diagnostic Addresses - Control Unit IR1 (StarFire™ 3000)

Group ITC: Integrated Terrain Compensation Addresses (ITC)

Diagnostic Addresses - Control Unit iTC (StarFire™ 3000)

Section 249: Electrical Component Information

Group 05: General Information

How to Navigate Section 249

Example Connector

Example of Harness Information

Group 40A: Electrical Assemblies

XA2

XA3

XA4

XA5

XA9

Group 40F: Fuses

XF7000

XF7001

Group 40W: Wiring Harnesses

W7000

W7001

W7002

Group 40X: Interconnects and Ground Points

XX7000

XX7118

XX7119

XX7120

XX7121

Group 40Z: Connector Repair Procedures

AMP® Connectors

Exploded View—CINCH™ FlexBox Connectors

CINCH™ 32 and 48 Way Connectors

DEUTSCH® Rectangular or Triangular Connectors

Install DEUTSCH® Contact

WEATHER PACK® Connectors

Install WEATHER PACK® Contact